Project Gutenberg's A Method of Tanning without Bark, by William Maple

This eBook is for the use of anyone anywhere in the United States and most
other parts of the world at no cost and with almost no restrictions
whatsoever.  You may copy it, give it away or re-use it under the terms of
the Project Gutenberg License included with this eBook or online at
www.gutenberg.org.  If you are not located in the United States, you'll have
to check the laws of the country where you are located before using this ebook.

Title: A Method of Tanning without Bark

Author: William Maple

Release Date: July 24, 2018 [EBook #57576]

Language: English

Character set encoding: UTF-8

*** START OF THIS PROJECT GUTENBERG EBOOK A METHOD OF TANNING WITHOUT BARK ***




Produced by The Online Distributed Proofreading Team at
http://www.pgdp.net (This file was produced from images
generously made available by The Internet Archive)

A
METHOD
OF
TANNING
WITHOUT
BARK.

DUBLIN:
Printed by A. Rhames, Mdccxxix

TO
His Excellency
William Conolly, Esq;
SPEAKER
OF THE
House of Commons of Ireland.
And to the Rest of the
Members of That HOUSE.
THIS
METHOD
OF
Tanning without BARK
Is humbly inscribed
By Their most
Obedient Servant,
William Maple.

[1]

THE
Method of Tanning
WITHOUT
BARK.

In Political Computations, the following Principles are universally allowed.

That the Riches of every Country arise from the Natural Produce of the Earth; and the Labour and Art, imployed in improving the same.

That the Quantity of Native Commodities, the Source of Riches, is in Proportion to the Number of People, fully and usefully employed.

That every industrious Person adds to the Wealth, and Support of a Nation; and every Idler, detracts from both, by living on the Labour of Others.

[2]

That it is the best Policy in any Government, to encourage, and provide for the full Imployment of the People; since thereby, the Number, Wealth, Strength, and Quiet of the Inhabitants are increased.

That the Gain, or Loss of any Nation by Trade, is known, and determined by the Proportion, which the Exports bear in Value to the Imports. On this depends the absolute Quantity of Money in a Nation; the Relative Quantity of the several Species, that composeth this Money, being ascertained by the Value imposed on those Species; either as it agrees with, or differs from the Value set thereon by other Nations.

A Nation certainly loses by a Trade, whose Exports are not compleatly manufactured, and whole Imports are fully wrought.

A few Manufactures will serve to exchange for great Quantities of the simple Produce of the Earth. The Value of Manufactures, being principally owing to Labour and Art.

If upon these Principles, we examine the State of the Trade of Ireland; I fear we shall find it, in a very declining, and ruinous Condition.

[3]

Our Exportations are made up of Wool, Woorsted, Linnen, Yarn, Beef, Butter, Cheese, Tallow, Hydes, Skins, and a few other Articles.

We are not allowed to export our Wool and Woorsted, but to a few Ports in England, and are prohibited from sending thither, or any where else, any other of our Woollen Manufacture. Linnen, and some tanned Hides are the only Commodities we export, compleatly Manufactured; Yarn and Woorsted may be accounted but as half-wrought; Almost all the other Articles are but little removed from the State, Nature has given them to us, and have little or no Labour or Art employed about them.

At the same Time, we export so liberally the Growth of our Country, and so little of our Manufactures, we may observe all our Importations are of such Commodities, as are not capable of farther Improvement; such as East-Indian and West-Indian Goods, Druggs, Wines, Spirits, Manufactures of Wool, Silk, Linnen, Iron, Brass, Glass, &c. Nay, the common Produce of almost all Countries, as Corn, Timber, and[4] Fireing, are imported in great Quantities to supply our Necessities.

By this Management of our Trade, we maintain many Thousands in foreign Countries, and drive Numbers of our own People from us, or leave them to starve at home, for Want of Imployment.

If to this View, we add that mighty Drain of our Bullion, made by those Gentlemen, who, having great Estates in this Kingdom, choose to spend them any where, rather than at home: We can not be at a Loss, how to account for the Ballance of Trade, running against us, for so many Years past.

The most certain Way left to retrieve our Affairs, is to lessen our Imports, and to encrease our Exports, especially of Manufactures.

The Commissioners of the Linnen Manufacture, by an unwearied Application and uncommon Skill, have contributed greatly to the Value of our Exports, by the Advancement of the Linnen Manufactury. And I don’t doubt but that in several other Articles, divers Expedients and Means,[5] may be thought of, for promoting a greater Consumption of our Own, and lessening that or foreign Commodities; and as one Instance, I shall beg Leave to propose an Improvement in our Tannage, by which I apprehend, we shall be enabled to Tan with the Produce of our own Country all the Hydes that now are Exported Raw; and thereby increase the Value of our Exports, employ many Thousands of our People, and avoid the Necessity of Importing Bark.

To set this Matter in a clear Light, I shall lay down, in the first Place, the Export of Green Hydes, and the Import of Bark, in the seven following Years, for the Whole Kingdom, as the same has been extracted out of the Custom-House Books.

[6]

In the next Place it is to be observ’d,

That Bark, according to its Goodness, is sold from 6 to 10, and in some Years, 11 Shillings, the Barrel.

That Cow-Hydes weigh from 56, to 84 Pounds each; Bullock Hydes, weigh from 84 to 140 Pounds each, and both are sold from 15 to 21 Shillings, the hundred Weight.

That Soles, are generally sold from 8 to 8 Pence half-penny the Pound.

That Hydes generally lose about half their Weight, in Tanning.

From these Principles, when thrown into mean Proportionate Quantities, it is evident:

That the Quantity of Bark, annually imported, is 50,000 Barrels, and the Value 21,000 Pounds.

That the Number of Green Hydes, annually exported, are 80,000, and their Value 57,000 Pounds.

That if these Green Hydes were tanned before Exportation, their Value would be 123,000 Pounds.

[7]

That the Difference, arising from the Different State of these Hydes, on Exportation, is 66,000 Pounds, which Sum added to the 21,000 Pounds, the Value of the imported Bark, making in the whole 87,000 Pounds, must be accounted, as so much gained to the Kingdom, should our Tannage be effected by our own Produce and Labour.

The Nations, that demand this Export of those Green Hydes, are those, whose black Cattle are not bred, in such Numbers, as to supply their indispensable Demands; Nor will their dry Hydes, which they receive from their Settlements abroad, admit a thorough Tannage; They, in hopes of putting their Neighbours, who have a Redundancy of Hydes, under a Necessity, of parting with them unmanufactured, have prohibited, by the severest Penalties, the sending us any Bark. While we, on the other Part, have not only complied with this detrimental Export; but also have been so regardless of our own Interest, as to permit several Tanners, some from this City, to go, and instruct them in an Art, they almost were Strangers to.

[8]

The English, from a true Sense of the Disadvantage of such a Trade, have subjected the Exporter of a Green Hyde, to the Penalties of 500 Pounds, and a Disability to trade in Leather, ever after. Ann. 14. Car. II.

Such an Act, even in our present Circumstances, may, by some, be thought adviseable for us; Because, such Nations, as now gladly receive our Green Hydes, finding a Stop, put to their usual Supplies, would be under a Necessity of receiving our tanned Hydes, and selling us their Bark. Leather being a Commodity, that does not depend on the Fancy; but, is absolutely requisite, not only to the Luxuries, but also, to the Necessities of Mankind.

At present, Our Tanners find a great Scarcity of Bark, except those residing in some considerable Sea-Port-Town, and are under just Apprehensions of a greater. Several in the Country have been obliged to lay aside their Pits, and take to other Imployments; the usual Supplies failing. Our Neighbours who will permit any Bark, to be sent us, are in a Manner exhausted. Our[9] American Plantations are too remote to find their Account, in sending any great Quantity. The Produce of our Country is scarce a twentieth Part of what is used in Tanning. This renders our Tannage dear, and often imperfect, so as not to serve a foreign Market, to Advantage, and Reputation.

But if we had Materials, of our own Growth, easy of Acquisition, and Propagation, that would tan, in every Respect, as well as Bark; were these Materials, as to their Powers, well ascertain’d, and confirm’d by a general Experience, the making an Act, to prohibit the Exportation of Green Hydes, would be judged by all to be Adviseable, and Useful to the Kingdom.

When the apparent Qualities of Bark, are considered; and that by it’s insinuating into the Pores, and incorporating with the Substance of the Hyde, it produces a Firmness, Strength, and Consolidation of the Parts; It is very surprizing, that other Materials, of the same Apparent Qualities, have so long remained neglected, and unapplied to the same Uses; when the Consequence is of such Moment.

[10]

Tormentil, and Cinquefoil Roots, are ranged in the same Medical Class; have the same apparent Qualities, especially the first, in a more eminent, and evident Degree, than Bark, it self.

On Tryal, they have answered beyond Expectation: The Cinquefoil did not give so good a Colour, as the Tormentil, which in all Respects, as to Colour, Bloom, Substance, Solidity, and Weight, in the Tanned Hyde, compleatly answered, and in much less Time, than when Bark, (even of the best Kind, or Growth) is used.

Tho’, what is here asserted, is grounded on several Years Experience, and confirmed by the Opinion and Testimony of Mr. Philip Cooley, Tanner, who from the Beginning hath been concerned in the several Tryals, and to whose Skill and Industry a Part of the Subsequent is owing. Yet to give the utmost Satisfaction, and as I think my self in the strongest Manner bound by the Encouragement, hitherto given me, by the House of Commons, to render the best Information I am able, in an Affair of some Consequence to the Public,[11] I shall give a most faithful Account of the Progress that has been made, and the Success that hath attended this Way of Tanning with relation to the Goodness of the Leather, the Time, and Charge of Tanning, and other Circumstances; and shall add several Observations, with Directions for finding, and propagating these Roots, in great Plenty, that all Persons may be encouraged to carry this Method of Tanning, into a general Practice, which as it will be for their private Advantage, so it will not fail to promote the Public Benefit.

In Order to this, I shall in the first Place beg Leave to place this Affair in the Light it appeared in before the Committee of the House of Commons of Ireland, to whom my Petition was referred by the House, in which Petition it was alledged, that I had established a Method of Tanning, without the Use of any Barks, to as great Perfection, cheaper, and in less Time, than with Bark, by Vegetables of our Natural Produce, and of easy Culture.

The Committee, were pleased, for their greater Satisfaction, to summon a Great[12] Number of Tanners, Curriers, Shoemakers, and others, to attend, to give their Testimony in relation to the several Specimens, and Proofs, that were to be laid before them.

In respect to the Goodness of the Leather, so tanned, the following Specimens were exhibited.

Nᵒ. 1. A Calve’s Skin from the Ooze.

Nᵒ. 2. A Calve’s Skin, uncurryed.

Nᵒ. 3. A Calve’s Skin, curried: each of these, when tann’d and dry’d, weighing about three Pounds.

Nᵒ. 4. A Calve’s Skin, very strong and large, when tanned and dryed, weighing about Six Pounds.

Nᵒ. 5. Seven or Eight Pair of Soles, of a Calve’s Skin, rais’d.

Nᵒ. 6. A Bend of a Bullock’s Hyde for Harness.

These were all proved by Thomas Cooley and Patrick Shale to be tanned without Bark, and with the Roots.

Mr. Henderson, Master of the Tanners, said he was diffident of the Goodness of the Specimens, that he should have been[13] thoroughly satisfyed: had he known, how the Leathers had proved, if worn, by some Porters, or Chairmen. That the Colour of Number 2, or 3, was not so good as some tanned with Bark, producing a Calve’s Skin curried, to compare with them, but did own, all the Specimens were thoroughly struck, and well tanned: That if they were in a Shop, intermixt with Skins, tanned by Bark, he could not distinguish them; and that, what tanned Numb. 5 and 6, would tann, Time and Quantity allowed, the thickest Bullock’s Hyde.

Mr. Dobson, Tanner, affirmed the Specimens were not well tanned, because they did not come up to the Colour of the Skin produced by Mr. Henderson, but in other Respects, the Leathers appeared, to be as good in their respective Kinds, as any tanned with Bark.

Mr. Nicholas Gibson, Master of the Curriers, affirmed that the Skin produced by Mr. Henderson, was of an Extraordinary Colour; That there were not ten such in Dublin; That the Difference in Colour was but very small, and in regard even to Colour,[14] would choose those tanned by the Vegetables, as soon as Mr. Henderson’s Skin; That all the Specimens appeared to be very well tanned, and that he could in no wise distinguish them from Bark-Tannage.

Mr. Devereux, Currier, being sent out, returned, producing two Calves Skins tanned by Bark, which he took indifferently, and without choosing, from the next Currier’s Shop. They were allowed by all, to be of a general or common Colour; and being compared were much exceeded by the Specimens, and particularly, as to Colour.

Mr. Edmund Sheild, Currier, said he never saw better tanned Leather, than the Specimens, that their Colour was very good and, that what tanned Numb. 5. would tann any Hyde, whatsoever.

Mr. Brookfield, Tanner, reported the Specimens exhibited, were well tanned and thoroughly struck; that neither He, or any other could distinguish them, from Bark Tannage; and that what tanned Numb. 5, could not fail in any Tannage.

[15]

Mr. Veckers, Tanner, allowed the Specimens to be very well tanned; and gave it, as his Opinion, that what tanned Numb. 5 and 6, would tann the thickest Sole Leather.

Mr. John Gades, Shoemaker, after giving his Testimony, that all the Specimens appeared to be exceedingly well tanned, produced a Shoe, made by him, of the Leather of this Tannage, affirming the Leather, wrought very well, and that the Soles exhibited, under the Hammer, all the Signs of extraordinary Leather.

Mr. Ellis, Shoemaker, reported the Specimens were very well tanned: That, Leather either dead, or highly tanned, would never carry so beautiful a Colour as Leather otherwise tanned. That, the Sole Leather appeared to be very well tanned; and that in his Opinion this Tannage, would in every respect, answer the same End, or Intentions, as Bark Tannage.

Mr. James King, Shoemaker, said all the Specimens, were effectually tanned.

Mr. Richard Norris, Shoemaker, produced a Sole of this Tannage, beaten; asserting[16] he never saw so good a Sole of rais’d Calve’s Skin, that it beat firm, solid, and without spreading, or Fuzziness: which are the distinguishing Characters of good Sole Leather, he desired it might be cut in several Places, that the Closeness, and Firmness might be view’d, which accordingly was done, and answering Expectation was approved.

There were a great many other Tanners, Curriers, and Shoemakers, who were of the same Opinion. But considering, their Testimonies, would be but so many Repititions; I shall not recite them.

Dr. Richard Helsham, Professor of Natural Philosophy in Trinity College, said I had communicated to him, what was used in this Tannage, which appeared to be well adapted to tanning, and would not fail to give a sufficient Strength, and Rigidity to the Fibres. Adding he wore a pair of Shoes, the Upper Leathers of this Tannage, daily for four Months, and being willing to try the utmost of the Leather, had new Soles put to them; that since he[17] had worn them about a Month: showing them, without any Cracks, or Defect.

Patrick Carrol, produced two Slips of curried Calf Skin; the one tanned by Bark, the other by the Roots, each three tenths of an Inch broad, and ten Inches long, the first was the thickest, and weighed, a tenth Part more than the other. He said, he was present with several others, when it broke, by a Weight of 129 Pounds being hung to it; That the Slip of this new Tannage, being tryed with the same Circumstances, bore 29 Pounds more than the 129 Pounds, before it either yielded, or broke.

In respect to Time.

That the Specimens, Nᵒ. 1, 2 and 3 were tanned in five Weeks, Nᵒ. 4 in nine Weeks, Nᵒ. 5 in four Months, without any Hurry, extraordinary, or illegal Methods: was proved by Mr. Thomas Cooley, and Patrick Shale; on the other Side, it appeared, that in tanning with Bark, from three to five Months were required for Calves Skins, from seven to nine were requisite for Soles of rais’d Calves Skins, and from ten to thirteen Months for Bullocks[18] Hydes, which by this Tannage, may be effected in nine or ten.

In regard to Cheapness.

Mr. Philip Cooley, affirmed that six Pounds of the Dry Roots, added to some old expended Ooze, tanned Six Calves Skins, three of which were produced under the Nᵒ. 1, 2, and 3; and that he believed sixteen Pounds would have done as much from the first, or without any old Ooze.

In relation to the Cheapness.

Part of the Roots, I have used, I purchased at three Farthings, the Pound; but of late Years, and being willing to engage the Privacy of the Gatherer; I have given a Penny; they lose about a third in Drying: Allowing these as Facts and taking it at the dearest, less than five Shillings worth of Roots, will go farther, than a Barrel of the best Bark.

As to their Plenty and Propagation, Dr. Helsham testified, they grew in great Plenty as he had observed, in several Counties of this Kingdom, and were very easily propagated.

[19]

Dr. William Stephens, Botanic Professor in Trinity College, Dublin, in his Examination declared, that they grew in great Plenty about Dublin, and in several Counties he had observed great Quantities, chiefly on Mountains, and barren Places: That, they were easily to be propagated, in almost any kind of Soil, and that he had some flourishing in the Physick Garden, belonging to the University.

The Resolutions, that the House entred into January 10, might very well have sufficed to have recommended a General Practice. But to remove some Prejudices and to obviate some false Representations, I have impartially recited the several Facts and Testimonies, on which they were founded.

That all People may easily know and find out these Plants, I shall here give a Description; which though tedious, I hope will be excused.

Cinquefoil, in Latin, Pentaphyllum vulgare, in Irish, Tuigbeag (Tuigbeag) Tuigvear Muirre (Tuigvear Muirre) and in some Counties, Meagigh, (Meagigh) is a Plant,[20] whose Roots are very long, about a Finger’s Thickness, of a dark brown or reddish Colour, and very astringent in Taste; the Leaves are born at the Extremity of a small Stem, five together, deeply indented on their Edges, of an oblong Form and hairy; on the Grand Stem, at the Nodes, shoot forth several smaller, terminating with a small Yellow Flower, composed of six small Leaves surrounding a Number of Threads, from whence ariseth a Cluster of Seeds.

It flourishes in every Hedge, sandy, loose and deep Soil: the Roots which are to be preferred, are the thick, long, and of the darkest Colour.

Tormentil, or Septfoil, in West Meath, called Neauhnadis (Neauhnadis) in Ulster, Menedin (Menedin) or Neauhnid (Neauhnid) in Connaught, Levenet (Levenet) in the County of Mayo, Fenede na Muc (Fenede na Muc) this Plant, hath a thick, tuberous Root, of a reddish brown Colour, sometimes covered with a black Skin, of a very astringent Taste, and shooting out many Fibres; the Leaves are generally seven,[21] set on the Extremity of a Foot Stalk, of a dark Green Colour, deeply indented on the Edges and hairy, from amidst them ariseth several small weak Stalks, of a reddish Colour, and hairy, about 12 or 18 Inches in Height, knotted; at every Knot, or Joint, is a Foliage, and two or three Foot Stalks, some bearing Leaves, and one longer than the rest the Flowers consisting of four Leaves, of a light Yellow Colour, to which succeeds the Seeds; the flower Cup, hath Eight Leaves, four large and four small, the Root when Vigorous sends forth several Runners, the Stalks of which are of a reddish Colour, and hairy that spread over the Ground; at every Joynt, from one Part ariseth two or three Stems, each bearing at the Extremity five Leaves, from the other Part, descend several Fibres that become Roots.

It grows almost every where, but chiefly delights in mountainy, barren and shallow Soils; the Roots seldom striking four or five Inches deep. It hath been observed by Dr. Stephens, to grow all along the Banks of the Doder, from Donore-Brook to[22] Old Baun, upon Roch Town Hills; it grows on the Borders of a great Bog for several Miles, by Rathmullian in the County of Meath. In the County of Wicklow, Thousands of Cart-Loads might be with Ease collected; Nor do I know a Mountain or Bog without Plenty of it.

In the Figure, (a) denotes the Root, (b) the Flower in the Bud, (c) the Flower expanded, (d) the Knob of Seeds, (e) the Runners, (f) the Flower Cup. I have exhibited but few of the Leaves, Stems, and Runners to avoid Confusion.

It is observable, that from the Bark of the Stalk of this Plant, at its breaking forth from the Root, excrementitious Tubercles or Knots, resembling Oak-Galls have been often discovered, and like them are subservient to the Propagation of Insects; which, considering the extream nice, and distinguishing Taste of those Animalculas, may well be allowed as a Proof, that their Juices are similar.

The Roots growing on Mountains are small, strong, and often have a black Coat; those that grow on the Sides of Loughs, and in Bogs, are large, of a lighter Colour; some I have had of the Latter, that have weighed each above half a Pound.

[23]

When you chose the Roots, prefer the large, knotty Roots, that when broken exhibit a blood red Tincture intermixt with the Brown, and those that when cut, leaves on the Knife a strong purple Colour.

The best Time for collecting these Roots is in the Winter Season, or early in the Spring, and tho’ the Seed-bearing Stalks, and Foliage are decayed, yet there are several Foot Leaves, that remain and direct the Inquirer.

And tho’ these Plants grow wild all over the Country, in such Plenty, as to be more than sufficient to tann all the Hydes, and Skins of the Kingdom; and little Apprehension of a Deficiency, for in digging up the Roots, there will be left some broken Parts, some Fibres, which will Vegetate and give a Supply. A common Root, on a moderate Computation will produce 8 or 10 hundred Seeds, these shedding, and dispersed by Winds, and other Accidents,[24] some will take Root, and carry on a Succession.

And in regard, it may be objected, that the Trouble and Expence, in gathering them, when in so dispers’d a Manner, would be very great; and a constant Supply uncertain: And because the Roots, if raised in such Soils, as shall be found to agree with them, would thereby become larger, stronger, as well as cheaper, I have endeavoured the Culture, especially of the Tormentil, and with such Success, as to have from each square Yard three Pounds weight of the Roots.

An Acre contains 7,840 square Yards; but, for Paths, Wastes, and inclosing, I would allow 1,800 Yards, not to be employed; As the first Year they will be little more than fibrous, I would allow three Years for their Growth, tho’, if another Year was added, the Crop by an Increase would sufficiently reward, not only as to Quantity but Quality; as the best of Lands are not required; I would state the Expence of that Culture as follows,

[25]

Suppose each square Yard, should produce but the Moiety of what before was mentioned, and sold but at three farthings the Pound, the Amount will be 27l. 3s. 6d. from whence a Profit ariseth beyond most of our Cultures, now in general Use, and the Tannage may be accomplished, at about a Moiety of the present Expence.

Probably, this Estimate of the Charge and Profit, may not be so exact as to be strenuously defended; but if defective, there is Room enough for any reasonable Addition or Deduction, without much Prejudice to the Argument; different Soils, often one and the same will be attended with different Charges; The finer, the Earth is made, or the more it is broken, before Planting the[26] better Vegetation succeeds; at first shooting up of the Herbage, particularly where the Ground is foul, houghing, or pulling up the large Weeds, will be necessary, that the Growth of the Tormentil may not be chequed; in a little Time it will clear its self. As the Roots run superficially, not streeking at most 5 or 6 Inches in perpendicular Depth, the Charge of digging them up cannot be so much, as that which attends Potatoes.

The Propagation may be effected by planting the Crowns of the Roots, (that Part, from whence the Herbage ariseth) in either Autumn or Spring, in the same manner as Horse Raddish, splitting the Crown, so as to leave a Bud on every Slice, then setting them in the Ground, about an Inch in Depth and allowing each Set, 5 or 6 Inches square of Ground. When you take up a Plantation, you will have an Abundance of small Roots that arose from the shedding of the Seed, and from the Runners, that will scarce be worth the Drying, but very proper for Planting: If you cut from either Extremity of the Root, a Piece of[27] about half an Inch in Length, it will grow very well. The whole Root, if cut into such Pieces, may be planted. In all these I believe the Charge of Planting might be saved; if you scatter them before Harrow, the passing of that over them, will cover them with Earth sufficient; or at least, the most Part of them.

You may Plant the Runners, as you do Strawberries, in the mention’d Seasons and Distances, and considering the Numbers of fibrous Roots, already shot forth, it may be allowed the speediest Method.

The Seeds ripen about August or September, when ripe, they are of brownish Colour; as they are very apt to shed, the Time of ripening must be heedfully regarded; It would be adviseable to cut the Hawm or Herbage, a little time before the Seeds ripen, laying it on a Cloth, or winnowing Sheet in the Sun, when dry, rub the Seeds out with your Hands, and separate them from the Chaff. In March the Ground being prepared, you may sow and harrow, or rake them into the Ground.

[28]

The Cutting of the young Stems, if planted in May, will grow.

The Roots when collected, are to be washed very clean, from the Earth that will remain with them, for otherwise, that Dirt when in the Layers, settleth into the Pores of the Hyde or Skin, and causeth Numbers of Spots, and Discolourations.

In fair Weather, it not being a succulent Root, they will sufficiently dry if spread on a Floor, or a clean Part of the Field; a little Wet, will in no case damage them. In case of very wet Weather, and continued, they may be Kiln dryed, in the same Manner as Bark.

When dryed, they must be bruised or ground, either more or less, according to the Uses design’d, or to the Proportion you require them to spend in. In case they should not be sufficiently washt, when they are pounded, or ground a little, it would be adviseable to sift the Dirt, or Earth, which by this Means is broken, and seperated from them.

When thus prepared, you must proceed in the same Manner, and lay away,[29] intirely, with the same Circumstances as with Bark.

It hath often been objected, That if this Method should obtain, Planting would be discouraged, and so prejudice the landed Interest. That it is used in the Canary Islands and that though it may be done effectually there, yet the Produce of our Country might have Qualities very different, or not exalted to such a Degree, as to be of a requisite Force.

To these, I would answer.

That Bark would always bear a Price, in Proportion to the Rate of what is substituted in lieu thereof; It would be far from being rendered useless, but only suffer a Diminution in Value.

That Diminution would be more than ballanced by the accelerated Growth, and Worth of the Timber. At present we fall our Woods so young, and at such improper Seasons, on Account of the Bark, that the Timber is neither so good, and little more than fit for Ribberies, and Cabbins; whereas otherwise, was the present Inducement, the great Price of Bark diminished, we[30] should have full, and well grown Timber, cut at a due Season, and proper for Edifices, and Shipping.

The Improvement of those Lands that now are unprofitable, or not far from such, would be another Ballance, if not wholly, yet in Part, to the apprehended Injury.

The Use of this Root hath not been confined to the Canaries. The Reverend Mr. Lucas Jacobson Debes, in his History of the Islands of Feroe says Page 120, “Here groweth a huge Quantity of Tormentil, which the Inhabitants, having no Bark of Trees to tan their Hydes with, make Use of; God and Nature having revealed to them the Dryness of that Herb, so that they tan their Skins with it, and therefore call it Bark.” And Page 271. “The Men wear Shoes of Neats Leather, tanned with the Roots of Tormentil.”

The first of these Islands, is in the Latitude of 28, the other in 62. Yet we find the same Roots used for the same Purposes, though probably they may differ in Degrees of Power.

[31]

A great Degree of Heat is not a Quality requisite to the Perfection of all Vegetables. Saffron in France exceeds the Produce of Spain, as much as the little we have in Ireland excells the Product of England.

Our Temperate Climate seems in some Degree, to be more adapted to Vegetables of this Species of Power, than those that are deemed hot. Our Bark is allowed to excel the Bark of those warmer Climates, as also our Timber.

It is a contested Point, whether the Tormentil is not the Plant, the Greeks called Britanica; probably so named from its plentiful Growth in that Island.

One great Advantage, arising from this Tannage should it become general, will be, that it will give Imployment to a great many Poor People, that will be set to work in gathering, or raising such a Quantity of those Roots, as will answer the present annual Import of Bark; as also the Tannage of some, if not the Whole of those Hydes, we now export unwrought; besides the[32] great Numbers, that will be employed in the encreased Tannage.

Thus, with as much Brevity, as the Nature of the Subject would admit of, I have given a Narrative, of what I hope will be as satisfactory, on a candid Perusal as I am assured, it will be beneficial to the Publick, in all its Consequences; if the Method laid down be but pursued with common Care, and Assiduity. It requiring no greater Skill than what at present is used in Bark Tannage; no Alterations in Forms, or Utensils.

If the Instructions, laid down, should appear to Any insufficient, or imperfect; I shall always with Pleasure be ready to render them, if in my Power otherwise. I have made a Plantation, very near this City, that if the Curiosity of Any should prompt them to a farther Information, in that Particular, they there may meet with it. As this Tannage is constantly carried on; it is open to the View of Any that desire it. I have several Thousands of Pounds weight of these Roots by me; I never refusing the buying of any brought to me.[33] If any Tanner wants, he may have it at the Price, I gave to the Countryman, or be directed where, or how to be supply’d, until a Demand makes it a Market Commodity.

Our Necessities, and those daily encreasing, first prompted to this Essay. The Authority of Books, I have not relied on, but a Series of Experiments that employed several Years in the Pursuit. If I have pointed out, or cleared from Incumbrances, an advantageous Path that may lessen the Import of Bark, extend our Tannage by our own Produce, and give a Support to any Number of Poor; I regard it in no other Sense, than having done Part of that Duty, I owe to a Country, which in Gratitude, I would call mine.

I might justly incur a severe Censure, if I should conclude, without testifying with all due Acknowledgements, a grateful Sense of my Obligations, to the Honourable House of Commons, for the Vote they were pleased to pass in my Favour, on the Report of the Committee; that I had, after a full Enquiry, answered the Allegations of my[34] Petition; and for the Resolution, they entred into, of giving all proper Encouragement to so useful a Proposal.

Far from being insensible, that all new Attempts of this Kind, are apt to subject the Author of them, to the Name of a Projector, and render him the Object of Reproach and Suspicion; when I was fully satisfied in the Facts, on which this Method is grounded; I communicated it to some Persons, who are as little liable to be impos’d on themselves, as they are above all Suspicion of imposing on others; under the Sanction of whole Characters, such an Imputation would at once be removed. By their Directions I preferred my Petition, and notwithstanding the Success was not altogether such as they desired; I hope they will not deny me the indulging a sincere Gratitude, in particulary owning the Obligations to them, who so warmly espoused my Interest, grounded upon that of the Nation. I shall venture to say no more, than as I flatter my self they can clear me from any Imputations of Sinister or Mercenary Views; So I can promise my[35] Endeavours shall always tend to hinder a Blush, for the Kind Representations, they have been pleased to make in my Favour; and that I shall always study to approve my self what is my chiefest Ambition to be, and what only intitles me to their Patronage; a Pretender to no other merit, but Plain dealing.

I should have published this sooner, but that I waited the Success of some repeated, as well as new Experiments; all which on the best Examination I am capable of making, have tended to an intire Confirmation; That the Tormentil Roots Tan all Hydes and Skins as effectually, cheaper, and in less Time than Bark, and is easily propagated.

End of Project Gutenberg's A Method of Tanning without Bark, by William Maple

*** END OF THIS PROJECT GUTENBERG EBOOK A METHOD OF TANNING WITHOUT BARK ***

***** This file should be named 57576-h.htm or 57576-h.zip *****
This and all associated files of various formats will be found in:
        http://www.gutenberg.org/5/7/5/7/57576/

Produced by The Online Distributed Proofreading Team at
http://www.pgdp.net (This file was produced from images
generously made available by The Internet Archive)

Updated editions will replace the previous one--the old editions will
be renamed.

Creating the works from print editions not protected by U.S. copyright
law means that no one owns a United States copyright in these works,
so the Foundation (and you!) can copy and distribute it in the United
States without permission and without paying copyright
royalties. Special rules, set forth in the General Terms of Use part
of this license, apply to copying and distributing Project
Gutenberg-tm electronic works to protect the PROJECT GUTENBERG-tm
concept and trademark. Project Gutenberg is a registered trademark,
and may not be used if you charge for the eBooks, unless you receive
specific permission. If you do not charge anything for copies of this
eBook, complying with the rules is very easy. You may use this eBook
for nearly any purpose such as creation of derivative works, reports,
performances and research. They may be modified and printed and given
away--you may do practically ANYTHING in the United States with eBooks
not protected by U.S. copyright law. Redistribution is subject to the
trademark license, especially commercial redistribution.

START: FULL LICENSE

THE FULL PROJECT GUTENBERG LICENSE
PLEASE READ THIS BEFORE YOU DISTRIBUTE OR USE THIS WORK

To protect the Project Gutenberg-tm mission of promoting the free
distribution of electronic works, by using or distributing this work
(or any other work associated in any way with the phrase "Project
Gutenberg"), you agree to comply with all the terms of the Full
Project Gutenberg-tm License available with this file or online at
www.gutenberg.org/license.

Section 1. General Terms of Use and Redistributing Project
Gutenberg-tm electronic works

1.A. By reading or using any part of this Project Gutenberg-tm
electronic work, you indicate that you have read, understand, agree to
and accept all the terms of this license and intellectual property
(trademark/copyright) agreement. If you do not agree to abide by all
the terms of this agreement, you must cease using and return or
destroy all copies of Project Gutenberg-tm electronic works in your
possession. If you paid a fee for obtaining a copy of or access to a
Project Gutenberg-tm electronic work and you do not agree to be bound
by the terms of this agreement, you may obtain a refund from the
person or entity to whom you paid the fee as set forth in paragraph
1.E.8.

1.B. "Project Gutenberg" is a registered trademark. It may only be
used on or associated in any way with an electronic work by people who
agree to be bound by the terms of this agreement. There are a few
things that you can do with most Project Gutenberg-tm electronic works
even without complying with the full terms of this agreement. See
paragraph 1.C below. There are a lot of things you can do with Project
Gutenberg-tm electronic works if you follow the terms of this
agreement and help preserve free future access to Project Gutenberg-tm
electronic works. See paragraph 1.E below.

1.C. The Project Gutenberg Literary Archive Foundation ("the
Foundation" or PGLAF), owns a compilation copyright in the collection
of Project Gutenberg-tm electronic works. Nearly all the individual
works in the collection are in the public domain in the United
States. If an individual work is unprotected by copyright law in the
United States and you are located in the United States, we do not
claim a right to prevent you from copying, distributing, performing,
displaying or creating derivative works based on the work as long as
all references to Project Gutenberg are removed. Of course, we hope
that you will support the Project Gutenberg-tm mission of promoting
free access to electronic works by freely sharing Project Gutenberg-tm
works in compliance with the terms of this agreement for keeping the
Project Gutenberg-tm name associated with the work. You can easily
comply with the terms of this agreement by keeping this work in the
same format with its attached full Project Gutenberg-tm License when
you share it without charge with others.

1.D. The copyright laws of the place where you are located also govern
what you can do with this work. Copyright laws in most countries are
in a constant state of change. If you are outside the United States,
check the laws of your country in addition to the terms of this
agreement before downloading, copying, displaying, performing,
distributing or creating derivative works based on this work or any
other Project Gutenberg-tm work. The Foundation makes no
representations concerning the copyright status of any work in any
country outside the United States.

1.E. Unless you have removed all references to Project Gutenberg:

1.E.1. The following sentence, with active links to, or other
immediate access to, the full Project Gutenberg-tm License must appear
prominently whenever any copy of a Project Gutenberg-tm work (any work
on which the phrase "Project Gutenberg" appears, or with which the
phrase "Project Gutenberg" is associated) is accessed, displayed,
performed, viewed, copied or distributed:

  This eBook is for the use of anyone anywhere in the United States and
  most other parts of the world at no cost and with almost no
  restrictions whatsoever. You may copy it, give it away or re-use it
  under the terms of the Project Gutenberg License included with this
  eBook or online at www.gutenberg.org. If you are not located in the
  United States, you'll have to check the laws of the country where you
  are located before using this ebook.

1.E.2. If an individual Project Gutenberg-tm electronic work is
derived from texts not protected by U.S. copyright law (does not
contain a notice indicating that it is posted with permission of the
copyright holder), the work can be copied and distributed to anyone in
the United States without paying any fees or charges. If you are
redistributing or providing access to a work with the phrase "Project
Gutenberg" associated with or appearing on the work, you must comply
either with the requirements of paragraphs 1.E.1 through 1.E.7 or
obtain permission for the use of the work and the Project Gutenberg-tm
trademark as set forth in paragraphs 1.E.8 or 1.E.9.

1.E.3. If an individual Project Gutenberg-tm electronic work is posted
with the permission of the copyright holder, your use and distribution
must comply with both paragraphs 1.E.1 through 1.E.7 and any
additional terms imposed by the copyright holder. Additional terms
will be linked to the Project Gutenberg-tm License for all works
posted with the permission of the copyright holder found at the
beginning of this work.

1.E.4. Do not unlink or detach or remove the full Project Gutenberg-tm
License terms from this work, or any files containing a part of this
work or any other work associated with Project Gutenberg-tm.

1.E.5. Do not copy, display, perform, distribute or redistribute this
electronic work, or any part of this electronic work, without
prominently displaying the sentence set forth in paragraph 1.E.1 with
active links or immediate access to the full terms of the Project
Gutenberg-tm License.

1.E.6. You may convert to and distribute this work in any binary,
compressed, marked up, nonproprietary or proprietary form, including
any word processing or hypertext form. However, if you provide access
to or distribute copies of a Project Gutenberg-tm work in a format
other than "Plain Vanilla ASCII" or other format used in the official
version posted on the official Project Gutenberg-tm web site
(www.gutenberg.org), you must, at no additional cost, fee or expense
to the user, provide a copy, a means of exporting a copy, or a means
of obtaining a copy upon request, of the work in its original "Plain
Vanilla ASCII" or other form. Any alternate format must include the
full Project Gutenberg-tm License as specified in paragraph 1.E.1.

1.E.7. Do not charge a fee for access to, viewing, displaying,
performing, copying or distributing any Project Gutenberg-tm works
unless you comply with paragraph 1.E.8 or 1.E.9.

1.E.8. You may charge a reasonable fee for copies of or providing
access to or distributing Project Gutenberg-tm electronic works
provided that

* You pay a royalty fee of 20% of the gross profits you derive from
  the use of Project Gutenberg-tm works calculated using the method
  you already use to calculate your applicable taxes. The fee is owed
  to the owner of the Project Gutenberg-tm trademark, but he has
  agreed to donate royalties under this paragraph to the Project
  Gutenberg Literary Archive Foundation. Royalty payments must be paid
  within 60 days following each date on which you prepare (or are
  legally required to prepare) your periodic tax returns. Royalty
  payments should be clearly marked as such and sent to the Project
  Gutenberg Literary Archive Foundation at the address specified in
  Section 4, "Information about donations to the Project Gutenberg
  Literary Archive Foundation."

* You provide a full refund of any money paid by a user who notifies
  you in writing (or by e-mail) within 30 days of receipt that s/he
  does not agree to the terms of the full Project Gutenberg-tm
  License. You must require such a user to return or destroy all
  copies of the works possessed in a physical medium and discontinue
  all use of and all access to other copies of Project Gutenberg-tm
  works.

* You provide, in accordance with paragraph 1.F.3, a full refund of
  any money paid for a work or a replacement copy, if a defect in the
  electronic work is discovered and reported to you within 90 days of
  receipt of the work.

* You comply with all other terms of this agreement for free
  distribution of Project Gutenberg-tm works.

1.E.9. If you wish to charge a fee or distribute a Project
Gutenberg-tm electronic work or group of works on different terms than
are set forth in this agreement, you must obtain permission in writing
from both the Project Gutenberg Literary Archive Foundation and The
Project Gutenberg Trademark LLC, the owner of the Project Gutenberg-tm
trademark. Contact the Foundation as set forth in Section 3 below.

1.F.

1.F.1. Project Gutenberg volunteers and employees expend considerable
effort to identify, do copyright research on, transcribe and proofread
works not protected by U.S. copyright law in creating the Project
Gutenberg-tm collection. Despite these efforts, Project Gutenberg-tm
electronic works, and the medium on which they may be stored, may
contain "Defects," such as, but not limited to, incomplete, inaccurate
or corrupt data, transcription errors, a copyright or other
intellectual property infringement, a defective or damaged disk or
other medium, a computer virus, or computer codes that damage or
cannot be read by your equipment.

1.F.2. LIMITED WARRANTY, DISCLAIMER OF DAMAGES - Except for the "Right
of Replacement or Refund" described in paragraph 1.F.3, the Project
Gutenberg Literary Archive Foundation, the owner of the Project
Gutenberg-tm trademark, and any other party distributing a Project
Gutenberg-tm electronic work under this agreement, disclaim all
liability to you for damages, costs and expenses, including legal
fees. YOU AGREE THAT YOU HAVE NO REMEDIES FOR NEGLIGENCE, STRICT
LIABILITY, BREACH OF WARRANTY OR BREACH OF CONTRACT EXCEPT THOSE
PROVIDED IN PARAGRAPH 1.F.3. YOU AGREE THAT THE FOUNDATION, THE
TRADEMARK OWNER, AND ANY DISTRIBUTOR UNDER THIS AGREEMENT WILL NOT BE
LIABLE TO YOU FOR ACTUAL, DIRECT, INDIRECT, CONSEQUENTIAL, PUNITIVE OR
INCIDENTAL DAMAGES EVEN IF YOU GIVE NOTICE OF THE POSSIBILITY OF SUCH
DAMAGE.

1.F.3. LIMITED RIGHT OF REPLACEMENT OR REFUND - If you discover a
defect in this electronic work within 90 days of receiving it, you can
receive a refund of the money (if any) you paid for it by sending a
written explanation to the person you received the work from. If you
received the work on a physical medium, you must return the medium
with your written explanation. The person or entity that provided you
with the defective work may elect to provide a replacement copy in
lieu of a refund. If you received the work electronically, the person
or entity providing it to you may choose to give you a second
opportunity to receive the work electronically in lieu of a refund. If
the second copy is also defective, you may demand a refund in writing
without further opportunities to fix the problem.

1.F.4. Except for the limited right of replacement or refund set forth
in paragraph 1.F.3, this work is provided to you 'AS-IS', WITH NO
OTHER WARRANTIES OF ANY KIND, EXPRESS OR IMPLIED, INCLUDING BUT NOT
LIMITED TO WARRANTIES OF MERCHANTABILITY OR FITNESS FOR ANY PURPOSE.

1.F.5. Some states do not allow disclaimers of certain implied
warranties or the exclusion or limitation of certain types of
damages. If any disclaimer or limitation set forth in this agreement
violates the law of the state applicable to this agreement, the
agreement shall be interpreted to make the maximum disclaimer or
limitation permitted by the applicable state law. The invalidity or
unenforceability of any provision of this agreement shall not void the
remaining provisions.

1.F.6. INDEMNITY - You agree to indemnify and hold the Foundation, the
trademark owner, any agent or employee of the Foundation, anyone
providing copies of Project Gutenberg-tm electronic works in
accordance with this agreement, and any volunteers associated with the
production, promotion and distribution of Project Gutenberg-tm
electronic works, harmless from all liability, costs and expenses,
including legal fees, that arise directly or indirectly from any of
the following which you do or cause to occur: (a) distribution of this
or any Project Gutenberg-tm work, (b) alteration, modification, or
additions or deletions to any Project Gutenberg-tm work, and (c) any
Defect you cause.

Section 2. Information about the Mission of Project Gutenberg-tm

Project Gutenberg-tm is synonymous with the free distribution of
electronic works in formats readable by the widest variety of
computers including obsolete, old, middle-aged and new computers. It
exists because of the efforts of hundreds of volunteers and donations
from people in all walks of life.

Volunteers and financial support to provide volunteers with the
assistance they need are critical to reaching Project Gutenberg-tm's
goals and ensuring that the Project Gutenberg-tm collection will
remain freely available for generations to come. In 2001, the Project
Gutenberg Literary Archive Foundation was created to provide a secure
and permanent future for Project Gutenberg-tm and future
generations. To learn more about the Project Gutenberg Literary
Archive Foundation and how your efforts and donations can help, see
Sections 3 and 4 and the Foundation information page at
www.gutenberg.org



Section 3. Information about the Project Gutenberg Literary Archive Foundation

The Project Gutenberg Literary Archive Foundation is a non profit
501(c)(3) educational corporation organized under the laws of the
state of Mississippi and granted tax exempt status by the Internal
Revenue Service. The Foundation's EIN or federal tax identification
number is 64-6221541. Contributions to the Project Gutenberg Literary
Archive Foundation are tax deductible to the full extent permitted by
U.S. federal laws and your state's laws.

The Foundation's principal office is in Fairbanks, Alaska, with the
mailing address: PO Box 750175, Fairbanks, AK 99775, but its
volunteers and employees are scattered throughout numerous
locations. Its business office is located at 809 North 1500 West, Salt
Lake City, UT 84116, (801) 596-1887. Email contact links and up to
date contact information can be found at the Foundation's web site and
official page at www.gutenberg.org/contact

For additional contact information:

    Dr. Gregory B. Newby
    Chief Executive and Director
    gbnewby@pglaf.org

Section 4. Information about Donations to the Project Gutenberg
Literary Archive Foundation

Project Gutenberg-tm depends upon and cannot survive without wide
spread public support and donations to carry out its mission of
increasing the number of public domain and licensed works that can be
freely distributed in machine readable form accessible by the widest
array of equipment including outdated equipment. Many small donations
($1 to $5,000) are particularly important to maintaining tax exempt
status with the IRS.

The Foundation is committed to complying with the laws regulating
charities and charitable donations in all 50 states of the United
States. Compliance requirements are not uniform and it takes a
considerable effort, much paperwork and many fees to meet and keep up
with these requirements. We do not solicit donations in locations
where we have not received written confirmation of compliance. To SEND
DONATIONS or determine the status of compliance for any particular
state visit www.gutenberg.org/donate

While we cannot and do not solicit contributions from states where we
have not met the solicitation requirements, we know of no prohibition
against accepting unsolicited donations from donors in such states who
approach us with offers to donate.

International donations are gratefully accepted, but we cannot make
any statements concerning tax treatment of donations received from
outside the United States. U.S. laws alone swamp our small staff.

Please check the Project Gutenberg Web pages for current donation
methods and addresses. Donations are accepted in a number of other
ways including checks, online payments and credit card donations. To
donate, please visit: www.gutenberg.org/donate

Section 5. General Information About Project Gutenberg-tm electronic works.

Professor Michael S. Hart was the originator of the Project
Gutenberg-tm concept of a library of electronic works that could be
freely shared with anyone. For forty years, he produced and
distributed Project Gutenberg-tm eBooks with only a loose network of
volunteer support.

Project Gutenberg-tm eBooks are often created from several printed
editions, all of which are confirmed as not protected by copyright in
the U.S. unless a copyright notice is included. Thus, we do not
necessarily keep eBooks in compliance with any particular paper
edition.

Most people start at our Web site which has the main PG search
facility: www.gutenberg.org

This Web site includes information about Project Gutenberg-tm,
including how to make donations to the Project Gutenberg Literary
Archive Foundation, how to help produce our new eBooks, and how to
subscribe to our email newsletter to hear about new eBooks.