The Project Gutenberg EBook of The Practical Distiller, by Samuel McHarry This eBook is for the use of anyone anywhere at no cost and with almost no restrictions whatsoever. You may copy it, give it away or re-use it under the terms of the Project Gutenberg License included with this eBook or online at www.gutenberg.org Title: The Practical Distiller An Introduction To Making Whiskey, Gin, Brandy, Spirits, &c. &c. of Better Quality, and in Larger Quantities, than Produced by the Present Mode of Distilling, from the Produce of the United States Author: Samuel McHarry Release Date: April 29, 2007 [EBook #21252] Language: English Character set encoding: ISO-8859-1 *** START OF THIS PROJECT GUTENBERG EBOOK THE PRACTICAL DISTILLER *** Produced by Robert Cicconetti, Marcia Brooks and the Online Distributed Proofreading Team at http://www.pgdp.net THE PRACTICAL DISTILLER: OR AN INTRODUCTION TO MAKING WHISKEY, GIN, BRANDY, SPIRITS, &c. &c. OF BETTER QUALITY, AND IN LARGER QUANTITIES, THAN PRODUCED BY THE PRESENT MODE OF DISTILLING, FROM THE PRODUCE OF THE UNITED STATES: _SUCH AS_ RYE, CORN, BUCK-WHEAT, APPLES, PEACHES, POTATOES, PUMPIONS AND TURNIPS. _WITH DIRECTIONS_ HOW TO CONDUCT AND IMPROVE THE PRACTICAL PART OF DISTILLING IN ALL ITS BRANCHES. _TOGETHER WITH DIRECTIONS_ FOR PURIFYING, CLEARING AND COLOURING WHISKEY, MAKING SPIRITS SIMILAR TO FRENCH BRANDY, &c. FROM THE SPIRITS OF RYE, CORN, APPLES, POTATOES, &c. &c. _AND SUNDRY EXTRACTS OF APPROVED RECEIPTS_ FOR MAKING CIDER, DOMESTIC WINES, AND BEER. BY SAMUEL McHARRY, OF LANCASTER COUNTY, PENN. PUBLISHED AT HARRISBURGH, (PENN.) BY JOHN WYETH. ----1809.---- DISTRICT OF _PENNSYLVANIA_, TO WIT: [Illustration: SEAL.] Be it remembered, that on the twenty fourth day of November, in the thirty-third year of the Independence of the United States of America, A. D. 1808, SAMUEL McHARRY, of the said district, hath deposited in this Office, the title of a Book, the right whereof he claims as author, in the words following, to wit: _The Practical Distiller: or an introduction to making Whiskey, Gin, Brandy, Spirits, &c. &c. of better quality, and in larger quantities, than produced by the present mode of distilling, from the produce of the United States: such as Rye, Corn, Buckwheat, Apples, Peaches, Potatoes, Pumpions and Turnips. With directions how to conduct and improve the practical part of distilling in all its branches. Together with directions for purifying, clearing and colouring Whiskey, making Spirits similar to French Brandy, &c. from the Spirits of Rye, Corn, Apples, Potatoes &c. &c. and sundry extracts of approved receipts for making Cider, domestic Wines, and Beer. By SAMUEL McHARRY, of Lancaster county, Pennsylvania._ In conformity to the act of the Congress of the United States, entitled, "An act for the encouragement of Learning, by securing the copies of Maps, Charts, and Books, to the Authors and proprietors of such copies during the times therein mentioned." And also to the act, entitled, "An act supplementary to an act, entitled, 'An act for the encouragement of Learning, by securing the copies of Maps, Charts, and Books, to the authors and proprietors of such copies during the time therein mentioned,' and extending the benefits thereof to the arts of designing, engraving, and etching historical and other prints." D. CALDWELL, _Clerk of the district of Pennsylvania._ CONTENTS: _Page_ SECTION I _Observations on Yeast._ 25 _Receipt for making stock Yeast._ 27 _Vessel most proper for preserving_ do. 30 _To ascertain the quality of_ do. 31 _To renew_ do. 32 _Observations on the mode in which distillers generally work_ do. 33 _How stock Yeast may be kept good for years._ 34 _To make best Yeast for daily use._ 36 SECTION II _Observations on the best wood for hogsheads._ 39 _To sweeten by scalding_ ditto. 41 Ditto, _burning_ do. 42 SECTION III _To mash rye in the common mode._ 44 _Best method of distilling rye._ 45 _To mash one-third rye with two-thirds corn._ 47 Do. _an equal quantity of rye and corn._ 49 Do. _two-thirds rye and one-third corn._ 51 Do. _corn._ 54 _To make four gallons to the bushel._ 55 _To know when grain is sufficiently scalded._ 58 _Directions for cooling off._ 59 _To ascertain when rye works well._ 61 _To prevent hogsheads from working over._ 62 SECTION IV _Observations on the quality of rye._ 63 _Mode of chopping rye._ 64 Do. _or grinding indian corn._ 65 Do. _malt._ 66 _To choose malt._ 67 _To build a malt-kiln._ 67 _To make malt for stilling._ 69 _Of hops._ 69 SECTION V _How to order and fill the singling still._ 69 _Mode of managing the doubling still._ 71 _On the advantages of making good whiskey._ 73 _Distilling buckwheat._ 77 _Distilling potatoes, with observations._ 78 _Receipt to prepare potatoes for distilling._ 82 _Distilling pumpions._ 83 Do. _turnips._ 83 Do. _apples._ 84 _To order_ do. _in the hogsheads._ 85 _To work_ do. _fast or slow._ 86 _To know when apples are ready for distilling._ 87 _To fill and order the singling still for apples._ 88 _To double apple-brandy._ 90 _To prepare peaches._ 91 _To double and single_ do. 92 SECTION VI _Best mode of setting stills._ 93 _To prevent the planter from cracking._ 98 _Method of boiling more than one still by a single fire._ 99 _To set a doubling still._ 100 _To prevent the singling still from rusting._ 101 SECTION VII _How to clarify whiskey._ 102 _To make a brandy, from rye, spirits or whiskey, to resemble French Brandy._ 103 _To make a spirit from_ ditto, _to resemble Jamaica spirits._ 104 Do. _Holland gin._ 105 Do. _country gin, and clarifying same._ 107 _On fining liquors._ 110 _On coloring liquors._ 111 _To correct the taste of singed whiskey._ 112 _To give an aged flavor._ 113 SECTION VIII _Observations on weather._ 115 Do. _water._ 117 _Precautions against fire._ 119 SECTION IX _Duty of the owner of a distillery._ 120 Do. _of a hired distiller._ 123 SECTION X _The profits arising from a common distillery._ 125 Do. _from a patent distillery._ 127 _Of hogs._ 129 _Diseases of hogs._ 133 _Feeding cattle and milk cows._ 134 SECTION XI _Observations on erecting distilleries._ 135 SECTION XII _On Wines._ 139 _Receipt for making ditto, from the autumn blue grape._ 140 Ditto, _from currants._ 142 Do. _for making cider, British mode._ 143 Do. do. _American mode._ 145 Do. _for an excellent American wine._ 150 Do. do. _honey wine._ 153 _To make elderberry wine._ 156 Do. do. _cordial._ 157 SECTION XIII _Of brewing beer._ 160 _Of the brewing vessels._ 160 _Of cleaning and sweetening casks and brewing vessels._ 161 _Of mashing or raking liquors._ 163 _Of working the liquor._ 167 _Of fining malt liquors._ 170 _Season for brewing._ 172 _To make elderberry beer or ebulum._ 173 _To make improved purl._ 174 _To brew strong beer._ 175 _To make china ale._ 176 _To make any new liquor drink as stale._ 177 _To recover sour ale._ 177 _To recover liquor that is turned bad._ 178 _Directions for bottling._ 178 _To make ale or beer of cooked malt._ 179 _To make treacle (or molasses) beer._ 181 PREFACE. When I first entered on the business of Distilling, I was totally unacquainted with it. I was even so ignorant of the process, as not to know that fermentation was necessary, in producing spirits from grain. I had no idea that fire being put under a still, which, when hot enough, would raise a vapour; or that vapour when raised, could be condensed by a worm or tube passing through water into a liquid state. In short, my impressions were, that chop-rye mixed with water in a hogshead, and let stand for two or three days; and then put into a still, and fire being put under her, would produce the spirit by boiling up into the worm, and to pass through the water in order to cool it, and render it palatable for immediate use--and was certain the whole art and mystery could be learned in two or three weeks, or months at farthest, as I had frequently met with persons who professed a knowledge of the business, which they had acquired in two or three months, and tho' those men were esteemed distillers, and in possession of all the necessary art, in this very abstruse science; I soon found them to be ignorant blockheads, without natural genius, and often, without principle. Thus benighted, and with only the above light and knowledge, I entered into the dark, mysterious and abstruse science of distilling, a business professed to be perfectly understood by many, but in fact not sufficiently understood by any. For it presents a field for the learned, and man of science, for contemplation--that by a judicious and systematic appropriation and exercise of certain elements, valuable and salutary spirits and beverages may be produced in great perfection, and at a small expense, and little inconvenience, on almost every farm in our country. The professed chymist, and profound theorist may smile at my ideas, but should any one of them ever venture to soil a finger in the practical part of distilling, I venture to say, he would find more difficulty in producing good yeast, than in the process of creating oxygen or hydrogen gas. Scientific men generally look down on us, and that is principally owing to the circumstance of so many knaves, blockheads and conceited characters being engaged in the business.--If then, the subject could be improved, I fancy our country would yield all the necessary liquors, and in a state of perfection, to gratify the opulent, and please the epicure. I had no difficulty in finding out a reputed great distiller, whose directions I followed in procuring every necessary ingredient and material for distilling, &c. He was industrious and attentive, and produced tolerable yield, but I soon found the quantity of the runs to vary, and the yield scarcely two days alike. I enquired into the cause, of him, but his answers were, he could not tell; I also enquired of other distillers, and could procure no more satisfactory answer--some attributed it to the water, others to witchcraft, &c. &c. I found them all ignorant--I was equally so, and wandered in the dark; but having commenced the business, I determined to have light on the subject; I thought there must be books containing instructions, but to my surprise, after a diligent search of all the book-stores and catalogues in Pennsylvania, I found there was no American work extant, treating on this science--and those of foreign production, so at variance with our habits, customs, and mode of economy, that I was compelled to abandon all hope of scientific or systematic aid, and move on under the instructions of those distillers of our neighborhood, who were little better informed than myself, but who cheerfully informed me of their experiments, and the results, and freely communicated their opinions and obligingly gave me their receipts. In the course of my progress, I purchased many receipts, and hesitated not to procure information of all who appeared to possess it, and sometimes at a heavy expense, and duly noted down all such discoveries and communications--made my experiments from time to time, and in various seasons, carefully noting down the results. Having made the business my constant and only study, carefully attending to the important branch of making yeast, and studying the cause and progress of fermentation, proceeding with numerous experiments, and always studying to discover the cause of every failure, or change, or difference in the yield. I could, after four years attention, tell the cause of such change, whether in the water, yeast, fermentation, quality of the grain, chopping the grain, or in mashing, and carefully corrected it immediately. By a thus close and indefatigable attention, I brought it to a system, in my mind, and to a degree of perfection, that I am convinced nothing but a long series of practice could have effected. From my record of most improved experiments, I cheerfully gave receipts to those who applied, and after their adoption obtaining some celebrity, I found applications so numerous, as to be troublesome, and to be impossible for me to furnish the demands gratis, of consequence, I was compelled to furnish to some, and refuse others; a conduct so pregnant with partiality, and a degree of illiberality naturally gave rise to murmurs. My friends strongly recommended a publication of them, the plan requiring the exercise of talents, order and method, with which I presumed myself not sufficiently versed, I for sometime obstinately refused, but at length and after reiterated solicitation, I consented to enter on the talk, under a flattering hope of affording useful information to those of my country engaged in the distillation of spirits from the growth of our native soil, which together with the following reasons, I offer as the only apology. 1st. I observed many distillers making fortunes, whilst others exercising an equal share of industry, and of equal merit were sinking money, owing to a want of knowledge in the business. 2d. In taverns I often observed foreign liquors drank in preference to those of domestic manufacture, though really of bad quality, possessing pernicious properties acquired from ingredients used by those in our commercial towns, who brew and compose brandies, spirits, and wines, often from materials most injurious to health, and this owing to so much bad liquor being made in our country, from which the reputation of domestic spirit has sunk. Whilst, in fact, we can make domestic spirits of various materials, which with a little management and age, will be superior to any of foreign produce. 3d. By making gin, &c. as good if not better, we might in a few years, meet those foreign merchants in their own markets, and undersell them; which we certainly could do, by making our liquors good, and giving them the same age. The transportation would of consequence improve them in an equal degree, for the only advantage their liquors of the same age have over our good liquors, is the mildness acquired by the friction in the warm hold of the ship in crossing the ocean. And moreover as liquors will be drank by people of all standings in society, I flattered myself I could improve our liquors, render them more wholesome to those whose unhappy habits compel a too free use of ardent spirits, and whose constitutions may have been doubly injured from the pernicious qualities of such as they were compelled to use. For there are in all societies and of both sexes, who will drink and use those beverages to excess, even when there exists a moral certainty, that they will sustain injury from such indulgence, and as an evidence of my hypothesis, I offer the free use of coffee, tea, &c. so universally introduced at the tables of people of every grade. The wise Disposer of worlds, very happily for mankind, permits the exhibition of genius, mind and talents, from the peasant and lower order, as well as from the monarch, the lord, and the opulent. To Europe they of course are not confined--Genius has already figured in our hemisphere--The arts and sciences are becoming familiar, they rise spontaneously from our native soil, and bid fair to vie with, if not out-shine accomplished Europe. In possession, then, of all the necessary materials, ingredients and requisites, I would ask why we cannot afford ardent spirits and wines equal to those imported; and thus raise our character to a standing with other countries, and retain those millions of dollars at home, which are yearly shipped abroad for those foreign liquors, so common, so universally in use, and much of which so adulterated, as to be followed, when freely used, with unhappy consequences. Would men of capital and science, turn their attention to distillations, from the produce of our own country, preserve the liquor until age and management would render it equal, if not superior to any imported; is it not probable that it would become an article of export, and most sensibly benefit our country at large. Considerations such as those have combined to determine a publication of my work; fully apprised of the scoffs of pedants, kicks, bites and bruises of critics--but I hope they will find latitude for the exercise of a share of compassion, when I inform them candidly, that a mill and distillery, or still house, were substituted for, and the only college and academy in which I ever studied, and those studies were broken, and during the exercise of my business, as a miller and distiller. That it contains errors in the diction and perspicuity, I will readily confess--but that it is in substance true, and contains much useful information, I must declare as an indisputable fact. And though the road I travelled was a new one, without compass, chart, or even star to steer by, not even a book to assist me in thinking, or cheer me in my gloomy passage--seeking from those springs of nature, and inherent endowments for consolatory aid--pressing on a frequently exhausted mind, for resources and funds, to accomplish the objects of my pursuits--not denying but that I met many of my fellow-beings, who cheerfully aided me with all the information in their power, and to whom I now present my thanks--I must acknowledge, I think my labors and exertions will prove useful to those of less experience than mine, in which event I shall feel a more ample remuneration for my exertions, than the price asked for one of those volumes. Could I have witnessed the publication of a similar work by a man of science and education, mine should never have appeared. But it would seem the learned and scientific have never considered a work of the kind as meriting their attention; a circumstance deeply to be regretted, as a finer colouring to a work of the same properties and value often procures celebrity, demand and currency. My object is to be useful, my style plain, and only laboured to be rendered easy to be understood, and convey the necessary instruction to those who may honor this work with a perusal, or resort to it for information, and that it may be useful to my countrymen, is the sincere wish of THE AUTHOR. INTRODUCTION. It is not more than twenty years since whiskey was first offered for sale in the seaport towns in large quantities; and then, owing to its badness, at a very low price. Since that period it has been gaining ground yearly, and at this time, it is the second great article of commerce, in the states of Pennsylvania and Maryland. In the interior of these states, it has nearly excluded the use of foreign distilled spirits, and I fancy might be made so perfectly pure and nice, as to ultimately supersede the use of any other throughout the United States. To assist in effecting this, the greatest attention should be paid to cleanliness, which in a distillery is absolutely necessary, the want of which admits of no excuse, where water is had without price. If a distiller does not by a most industrious well-timed care and attention, preserve every utensil perfectly sweet and clean, he may expect, notwithstanding he has well attended to the other branches, but indifferent whiskey and not much of it. If, for instance, every article, or only one article in the composition of yeast be sour or dirty, that one article will most assuredly injure the whole; which being put into a hogshead of mashed grain, soon imparts its acidity or filth to the whole mass, and of course will reduce the quantity and quality of the spirit yielded from that hogshead. Cleanliness in every matter and thing, in and about a distillery becomes an indispensable requisite, without a strict observance of which the undertaker will find the establishment unproductive and injurious to his interest. Purity cannot exist without cleanliness. Cleanliness in the human system will destroy an obstinate itch, of consequence, it is the active handmaid of health and comfort, and without which, decency does not exist. Care is another important and necessary consideration, and a basis necessary, on which to erect a distillery, in order to ensure it productive of wealth and reputation. Care and industry will ensure cleanliness; an eye of care must be extended to every thing, that nothing be lost, that every thing be in its proper place and order, that every thing be done in due time; the business must be well timed, and time well economised, as it ranks in this, as in every other business very high. Let a judicious attention be paid to care, cleanliness, and industry, and when united with a competent knowledge of the different branches of the distilling business, the character of a compleat practical distiller is perfect. With such a distiller, and a complete still-house, furnished with every necessary utensil for carrying on the business--it cannot fail to prove a very productive establishment, and present to the world, from the materials of our own farms, a spirit as wholesome, and well flavored and as healthy as any spirit whatever--the produce or yield of any country, provided it be permitted to acquire the same age. What a grand and great idea strikes the thinking scientific mind, on entering a complete and clean distillery, with an intelligent cleanly distiller, performing his duty in it. To see the four elements, each combining to produce (with the assistance of man) an article of commerce and luxury, and at the same time, a necessary beverage to man. The earth producing the grain, hops and utensils, which a combination of fire and water reduces into a liquid by fermentation, and when placed in the still to see air engaging fire to assist her in reducing the liquid that fire and water had produced, into a vapour, or air, and afterwards to see fire abandoning air, and assisting water to reduce it into a liquid by means of the condensing tubes, and then to consider the number of hands employed in keeping the distillery a going, will present one other patriotic idea. The farmer with all his domestics and people, engaged in the cultivation of the rye, corn, &c. The wood choppers--the haling--the coopers engaged in making casks--the hands engaged in feeding cattle and the pork--haling, barrelling and selling the whiskey, spirits, pork, &c. The produce of the distillery, presenting subject for commerce, and employ for the merchant, mechanic and mariner--and all from our own farms. After seeing the distillery afford employment for so many hands, bread to their families, and yielding the means of an extensive revenue and increase of commerce--with a flattering prospect of completely annihilating the use of foreign liquors in our country, and thereby saving the expenditure of millions of dollars; and ultimately rendering our liquors an article of export and source of wealth--I presume every mind will be struck with the propriety of encouraging a branch of business so promising in wealth and comfort. The following receipts are intended to convey all the instruction necessary in the science of distilling, and producing from the growth of our own farms, the best spirits of every description, and such as I flatter myself will supersede the use of all imported liquors, and thereby fulfil the views and wishes of THE AUTHOR. PRACTICAL DISTILLER. SECTION I. _Observations on Yeast._ That yeast is the main spring in distilling, is acknowledged by all distillers, tho' but few if them understand it, either in its nature or operation; tho' many pretend a knowledge of the grand subject of fermentation, and affect to understand the best mode of making stock yeast, and to know a secret mode unknown to all others--when it is my belief they know very little about it; but, by holding out the idea of adding some drug, not to be procured at every house, which has a hard name, and that is little known to people of common capacities: Such as Dragons blood, &c. frequently retailing their secret, as the best possible mode of making stock yeast, at ten, twenty, and in some instances one hundred dollars. Confessing it a subject, abstruse, and a science little understood in Pennsylvania, and notwithstanding the numerous experiments I have made with care and close observation, yet from a consciousness of not understanding it, _too well_, I have in several instances purchased receipts, and made faithful experiments; but have never yet met the man of science, theory, or practice, whose mode of making stock yeast, yielded a better preparation for promoting fermentation, than the simple mode pursued by myself for some years, and which I have uniformly found to be the best and most productive. In making yeast, all drugs and witchcraft are unnecessary--Cleanliness, in preserving the vessels perfectly sweet, good malt, and hops, and an industrious distiller, capable of observation, and attention to the following receipt, which will be assuredly found to contain the essence and spirit of the ways and art of making that composition, a knowledge of which I have acquired, by purchases--consultations with the most eminent brewers, bakers, and distillers in this commonwealth, and above all, from a long practice and experience, proving its utility and superior merits to my most perfect satisfaction; and which I with pleasure offer to my fellow-citizens, as meriting a preference--notwithstanding the proud and scientific chymist, and the flowery declarations or treatises of the profound theorist, may disapprove this simple mode, and offer those which they presume to be better, tho' they never soiled a finger in making a practical experiment, or perhaps witnessed a process of any description. ARTICLE II. _Receipt for Stock Yeast._ _For a stock yeast vessel of two gallons, the size best adapted for that purpose._ Take one gallon good barley malt, (be sure it be of good quality) put it into a clean, well scalded vessel, (which take care shall be perfectly sweet) pour thereon four gallons scalding water, (be careful your water be clean) stir the malt and water with a well scalded stick, until thoroughly mixed together, then cover the vessel close with a clean cloth, for half an hour; then uncover it and set it in some convenient place to settle, after three or four hours, or when you are sure the sediment of the malt is settled to the bottom, then pour off the top, or thin part that remains on the top, into a clean well scoured iron pot, (be careful not to disturb the thick sediment in the bottom, and that none of it goes into the pot); then add four ounces good hops, and cover the pot close with a clean scalded iron cover, and set it on a hot fire of coals to boil--boil it down one third, or rather more, then strain all that is in the pot through a thin hair sieve, (that is perfectly clean) into a clean well scalded earthen crock that is glazed--then stir into it, with a clean stirring stick, as much superfine flour as will make it about half thick, that is neither thick nor thin, but between the two, stirring it effectually until there be no lumps left in it. If lumps are left, you will readily perceive that the heart or inside of those lumps will not be scalded, and of course, when the yeast begins to work, those lumps will sour very soon, and of course sour the yeast--stir it then till those lumps are all broken, and mixed up, then cover it close for half an hour, to let the flour stirred therein, be properly scalded, after which uncover and stir it frequently until it is a little colder than milk warm, (to be ascertained by holding your finger therein for ten minutes, but beware your finger is clean) then add half a pint of genuine good yeast,[1] (be certain it is good, for you had better use none, than bad yeast) and stir it effectually, until you are sure the yeast is perfectly incorporated with the ingredients in the pot--after which cover it, and set it in a moderately cool place in summer, until you perceive it begin to work, or ferment--then be careful to stir it two or three times at intervals of half an hour--then set it past to work--in the winter, place it in a moderately warm part of the still-house--and in summer, choose a spring house, almost up to the brim of the crock in water--avoiding extremes of heat or cold, which are equally prejudicial to the spirit of fermentation--of consequence, it should be placed in a moderately warm situation in the winter, and moderately cool in the summer. [Footnote 1: If none can be obtained that is good, the following is a receipt to make it, viz. Procure three wooden vessels of different sizes and apertures, one capable of holding two quarts, the other three or four, and the third five or six; boil a quarter of a peck of malt for about eight or ten minutes in three pints of water; and when a quart is poured off from the grains, let it stand in a cool place till not quite cold, but retaining that degree of heat which the brewers usually find to be proper when they begin to work their liquor. Then remove the vessel into some warm situation near a fire, where the thermometer stands between 70 and 80 degrees (Fahrenheit,) and here let it remain till the fermentation begins, which will be plainly perceived within thirty hours; add then two quarts more of a like decoction of malt, when cool, as the first was; and mix the whole in the larger sized vessel, and stir it well in, which must be repeated in the usual way, as it rises in a common vat: then add a still greater quantity of the same decoction, to be worked in the largest vessel, which will produce yeast enough for a brewing of forty gallons.] This yeast ought to be renewed every four or five days in the summer, and eight or ten days in the winter--but it is safer to renew it oftener, or at shorter intervals, than suffering it to stand longer. In twenty-four hours after it begins to work, it is fit for use. Between a pint and half a pint of the foregoing stock yeast, is sufficient to raise the yeast for the daily use of three hogsheads. ART. III. The most proper vessel for preserving stock yeast is an earthen crock, that will hold three gallons at least, with a cover of the same, well glazed--as it will contract no acid from the fermentation, and is easily scalded and sweetened. There ought to be two of the same size, that when one is in use, the other may be sweetening--which is effected by exposing them to frost or fire. ART. IV. _To know when Yeast is good or bad._ When you perceive your yeast working, observe if it works quick, sharp and strong, and increasing in bulk nearly double what it was before it began to work, with a sweet sharp taste, and smell, with the appearance of a honey comb, with pores, and always changing place, with a bright lively colour, then you may pronounce your yeast good; on the contrary, if it is dead, or flat and blue looking, with a sour taste, and smell, (if any at all,) then you may pronounce it bad, and unfit for use, and of course must be renewed. ART. V. _How to renew Yeast when sour._ About two hours before you begin to make your beer, take one pint of the sour yeast, put it into a clean dish or vessel, and pour clean cold water over it--changing the water every fifteen minutes, until the acid be extracted, have it then in readiness to mix with the beer, which is to be prepared, in the following manner, viz. Take one pint malt, and scald it well in a clean vessel, with a gallon of boiling water, let it stand half an hour closely covered--then pour it into a pot with plenty of hops--then strain it into a well scalded earthen jug, when milk warm--add then a small quantity of the yeast, (sweetened as directed in the first part of this receipt,) with two or three table spoon fulls of molasses ... set it past for twenty four hours to ferment ... then pour off the top, or beer that is in the jug, leaving about a quart in the bottom ... then that which remains in the bottom will be yeast with which to start your stock yeast. ART. VI. The method of procuring and keeping stock yeast, by the generality of distillers, merits in the mind of the author of this work, most decided disapprobation. They generally procure yeast once a week, or month, from brewers, and if not convenient to be had in this way, they often use such as is used by country women, for baking bread, without paying any regard to the quality, or whether sour; with such, tho' generally bad, they proceed to make their daily yeast, and often continue the use of it, until the grain will no longer yield a gallon of whiskey to the bushel, and so often proceed in this miserable and indolent mode of procuring and renewing yeast, to the great prejudice of their own, and employer's interest ... attributing the small yield of liquor to the badness of the grain ... the manner in which it is chopped, or some other equally false cause. Then to the idle and careless habits of distillers, must be attributed any yield short of three gallons to the bushel of rye.... To ensure this quantity at least from the bushel, the author discovers the anxiety expressed, and the care recommended in the foregoing pages, on the subject of preserving and keeping good yeast, and recommends the following as the best mode of preparing. ART. VII. _Stock Yeast good for years._ When the weather is moderately warm in autumn or the spring, take of your best stock yeast that has fermented about twenty four hours, and stir it thick with the coarsest middlings of wheat flour, add small quantity of whiskey, in which, previously dissolve a little salt, when you have stirred the middlings with a stick, rub it between your hands until it becomes pretty dry, then spread it out thin, on a board to dry in the sun ... rubbing once or twice in the day between your hands until it is perfectly dry, which will be in three or four good days--taking it in at night before the dew falls--when it is properly dried, put it up in a paper and keep it in a dry airy place for use. Thus yeast will keep good, if free from moisture, for any length of time, and it is the only effectual mode of preserving stock yeast pure and sweet ... when put up conformably to the foregoing instructions, the distiller may always rely on having it good, and depend on a good turn out of his grain, provided he manages the other parts of his distilling equally well. About two hours before you mean to use the dried yeast, the mode is to take two gills, place it in any convenient vessel, and pour thereon milk-warm water, stir and mix it well with the yeast, and in two or three hours good working yeast will be produced. In the spring every distiller ought to make as much as would serve 'till fall, and every fall as much as will serve thro' the winter, reckoning on the use of one pint per week, three gills being sufficient to start as much stock yeast as will serve a common distillery one week. ART. VIII. _To make the best Yeast for daily use._ For three hogsheads take two handfuls of hops, put them into an iron pot, and pour thereon three gallons boiling water out of your boiler, set the pot on the fire closely covered half an hour, to extract the strength from the hops, then strain it into your yeast vessel, thicken it with chopped rye, from which the bran has been sifted ... stir it with a clean stick until the lumps are all well broken and mixed ... cover it close with a cloth for half an hour, adding at the time of putting in the chopped rye, one pint of good malt when the rye is sufficiently scalded, uncover and stir it well until it is milk-warm, then add one pint good stock yeast, stirring until you are sure it is well mixed with the new yeast. If your stock yeast is good, this method will serve you ... observing always, that your water and vessels are clean, and the ingredients of a good quality; as soon as you have cooled off and emptied your yeast vessel, scald and scour, and expose it to the night air to purify. Tin makes the best yeast vessel for yeast made daily, in the above mode. In the course of my long practice in distilling I fully discovered that a nice attention to yeast is absolutely necessary, and altho' I have in the foregoing pages said a great deal on the subject, yet from the importance justly to be attached to this ingredient in distilling, and to shew more fully the advantages and disadvantages arising from the use of good and bad yeast, I submit the following statement for the consideration of my readers. Advantages in using good yeast for one month, at 5 bushels per day; 30 days at 5 bushels, is 150 bushels at 60 cents, costs $ 90 00 Contra 150 bushels yield 3 gallons per bushel, at 50 cents per gallon--450 gallons, 225 00 -------- Profit $ 135 00 Disadvantages sustained during the above period. 150 bushels at 60 cents, $ 90 00 Contra 150 bushes yielding 1-1/2 gallons to the bushel--225 gallons at 50 cents, 112 50 ------- Profit $ 21 50 Thus the owner or distiller frequently sustains in the distillation of his produce, a loss, equal and in proportion to the foregoing--from the use of indifferent yeast, and often without knowing to what cause to attribute it. This statement will shew more forcibly, than any other mode--and is made very moderate on the side of indifferent yeast, for with bad sour yeast the yield will be oftener under one gallon to the bushel than above one and an half--whereas with good yeast the yield will rarely be so low as three gallons to the bushel. It is therefore, I endeavor so strongly to persuade the distiller to pay every possible attention to the foregoing instructions, and the constant use of good yeast only, to the total rejection of all which may be of doubtful quality. SECTION II. ARTICLE I. _Observations on Wood for Hogsheads._ The cheapest and easiest wrought wood is generally most used for making mashing tubs, or hogsheads, and very often for dispatch or from necessity, any wood that is most convenient is taken, as pine or chesnut; indeed I have seen poplar tubs in use for mashing, which is very wrong, as a distiller by not having his hogsheads of good wood, may lose perhaps the price of two sets of hogsheads in one season. For instance, a farmer is about to erect a distillery, and is convenient to a mountain, abounding in chesnut or pine, which from its softness and the ease with which it may be worked, its convenience for dispatch sake, is readily chosen for his mashing hogsheads.--To such selection of wood, I offer my most decided disapprobation, from my long experience, I know that any kind of soft wood will not do in warm weather. Soft porus wood made up into mashing tubs when full of beer and under fermentation, will contract, receive or soak in so much acid, as to penetrate nearly thro' the stave, and sour the vessel to such a degree, in warm weather, that no scalding will take it out--nor can it be completely sweetened until filled with cold water for two or three days, and then scalded; I therefore strongly recommend the use of, as most proper _White Oak._ Disapproving of black, tho' next in order to white oak staves for all the vessels about the distillery ... as being the most durable of close texture, easily sweetened ... and hard to be penetrated by acids of any kind, tho' sometimes the best white oak hogsheads may sour, but two or three scaldings will render them perfectly sweet ... if white oak cannot be had, black oak being of the next best in quality may be used ... and again I enter my protest against pine, chesnut, poplar, and every kind of soft porus wood. If possible, or if at all convenient, have the vessels iron bound and painted, to prevent worms and the weather from injuring them, using one good wood hoop on the bottom to save the chine. ART. II. _To sweeten Hogsheads by scalding._ When you turn your vessels out of doors (for it is esteemed slothful and a lazy mode to scald them in the still house,) you must wash them clean with your scrubbing brush, then put in sixteen or twenty gallons boiling water--cover it close for about twenty minutes, then scrub it out effectually with your scrubbing broom, then rinse your vessel well with a couple buckets clean cold water, and set them out to receive the air--this method will do in the winter, provided they are left out in the frost over night--but in summer, and especially during the months of July and August, this mode will not do--it is during those extreme warm months in our latitude, that the vessels are liable to contract putrid particles, which may be corrected by the following mode of making _Hogsheads perfectly sweet._ Scald them twice, as above directed, then light a brimstone match, flick it on the ground, turn your hogshead down over it, let it stand until the match quits burning, this operation is necessary once a week--a method I have found effectual. ART. III. _To sweeten Hogsheads by burning._ When you have scalded your hogsheads well, put into each, a large handful of oat or rye straw, set it on fire, and stir it till it is in a blaze, then turn the mouth of the hogshead down; the smoke will purify and sweeten the cask. This process should be repeated every other day, especially during summer--it will afford you good working casks, provided your yeast be good, and your hogsheads are well mashed. There ought always to be in a distillery more vessels than are necessary for immediate use, that they may alternately be exposed to the frost and air one night at least before brought into service, always bearing in mind that the utmost attention to cleanliness is necessary, in order to afford such yield from the grain, or fruit, as may be requisite to compensate for the expense and labor of extracting spirits--and moreover, that the exercise of the finest genius possessed by man is scarcely capable of taking from small grain, all the spirit it contains:.... good materials will not suffice ... the most marked attention is indispensably necessary to yeast; a mind capable of judging of fermentation in all its stages ... a close adherence to the manner of using the ingredients ... preparing them, and the use of sweet vessels, with great industry and a knowledge to apply it at the proper moment, are all necessary to enable the accomplishment of the desired end. Note ... In scalding your hogshead I would recommend the use of a shovel full of ashes, which will scald more sharply. SECTION III. ARTICLE I. _To Mash Rye in the common mode._ Take four gallons cold water to each hogshead, add one gallon malt, stir it well with your mashing stick, until the malt is thoroughly wet--when your still boils, put in about sixteen gallons boiling water, then put in one and an half bushels of chopped rye, stirring it effectually, until there is no lumps in it, then cover it close until the still boils, then put in each hogshead, three buckets or twelve gallons boiling water, stirring it well at the same time--cover it close--stir it at intervals until you perceive your rye is scalded enough, which you will know by putting in your mashing stick, and lifting thereon some of the scalded rye, you will perceive the heart or seed of the rye, like a grain of timothy seed sticking to the stick, and no appearance of mush, when I presume it will be sufficiently scalded--it must then be stirred until the water is cold enough to cool off, or you may add one bucket or four gallons of cold water to each hogshead, to stop the scalding. I have known this process succeed well with an attentive distiller. ART. II. _The best method of distilling Rye._ Take four gallons boiling, and two gallons cold water--put it into a hogshead, then stir in one and a half bushels chopped rye, let it stand five minutes, then add two gallons cold water, and one gallon malt, stir it effectually--let it stand till your still boils, then add sixteen gallons boiling water, stirring it well, or until you break all the lumps--then put into each hogshead, so prepared, one pint coarse salt, and one shovel full of hot coals out of your furnace. (The coals and salt have a tendency to absorb all sourness and bad smell, that may be in the hogshead or grain;) if there be a small quantity of hot ashes in the coals, it is an improvement--stir your hogsheads effectually every fifteen minutes, keeping them close covered until you perceive the grain scalded enough--when you may uncover, if the above sixteen gallons boiling water did not scald it sufficiently, water must be added until scalded enough--as some water will scald quicker than others--it is necessary to mark this attentively, and in mashing two or three times, it may be correctly ascertained what quantity of the kind of water used will scald effectually--after taking off the covers, they must be stirred effectually, every fifteen minutes, till you cool off--for which operation, see "_Cooling off._" To those who distill all rye, I recommend this method, as I have found it to answer every kind of water, with one or two exceptions. Distillers will doubtless make experiments of the various modes recommended and use that which may prove most advantageous and convenient. ART. III. _To Mash two thirds Rye and one third Corn in Summer._ This I have found to be the nicest process belonging to distilling--the small proportion of corn, and the large quantity of scalding water, together with the easy scalding of rye, and the difficulty of scalding corn, makes it no easy matter to exactly hit the scald of both; but as some distillers continue to practice it, (altho' not a good method in my mind, owing to the extreme nice attention necessary in performing it.) In the following receipt I offer the best mode within my knowledge, and which I deem the most beneficial, and in which I shew the process and mode pursued by other distillers. Take four gallons cold water, put it into a hogshead, then stir half a bushel corn into it, let it stand uncovered thirty minutes, then add sixteen gallons boiling water, stir it well, cover it close for fifteen minutes, then put in your rye and malt and stir it until there be no lumps, then cover it and stir it at intervals until your still boils, then add, eight, twelve, or sixteen gallons boiling water, or such quantity as you find from experience, to answer best--(but with most water, twelve gallons will be found to answer) stirring it well every fifteen minutes until you perceive it is scalded enough, then uncover and stir it effectually until you cool off; keeping in mind always that the more effectually you stir it, the more whiskey will be yielded. This method I have found to answer best, however, I have known it to do very well, by soaking the corn in the first place, with two gallons warm, and two gallons cold water, instead of the four gallons of cold water, mentioned above--others put in the rye, when all the boiling water is in the hogshead, but I never found it to answer a good purpose, nor indeed did I ever find much profit in distilling rye and corn in this proportion. ART. IV. _To distill one half Rye and one half Corn._ This method of distilling equal quantities of rye and corn, is more in practice, and is much better than to distill unequal proportions, for reason you can scald your corn and rye to a certainty, and the produce is equal if not more, and better whiskey, than all rye. The indian corn is cheaper, and the seed is better than if all rye. I would recommend this, as the smallest quantity of corn to be mixed with rye for distillation, as being most productive, and profitable. The following receipt I have found to answer all waters--yet there may be places where the distiller cannot follow this receipt exactly, owing to hard or soft water, (as it is generally termed) or hard flint or soft floury corn, that will either scald too much or too little--but this the attentive distiller will soon determine by experience. Have your hogshead perfectly sweet, put into each, three gallons of cold and three of boiling water, or more or less of each, as you find will answer best--then stir in your corn--fill up your boiler, bring it briskly to a boil--then put to each hogshead twelve gallons boiling water, giving each hogshead one hundred stirs, with your mashing stick, then cover close, fill up your boiler and keep a good fire under her, to produce a speedy boil; before you add the last water, put into each hogshead one pint of salt, and a shovel full of hot coals and ashes from under your still, stir the salt and coals well, to mix it with your corn, the coal will remove any bad smell which may be in the hogshead--Should you find on trial, that rye don't scald enough, by putting it in after your last water, you may in that case put in your rye before the last water--but this should be ascertained from several experiments. I have found it to answer best to put in the rye after all the water is in the hogshead, especially if you always bring the still briskly to a boil--then on your corn put twelve or sixteen gallons boiling water, (for the last water,) then if you have not already mashed in your rye, put it in with one gallon good malt to each hogshead, carefully stirring it immediately very briskly, for fear of the water loosing its heat, and until the lumps are all broken, which you will discover by looking at your mashing stick; lumps generally stick to it. When done stirring, cover the hogshead close for half an hour, then stir it to ascertain whether your grain be sufficiently scalded, and when nearly scalded enough, uncover and stir steady until you have it cool enough to stop scalding; when you see it is scalded enough, and by stirring that the scalding is stopped, uncover your hogsheads, and stir them effectually, every fifteen minutes, until they are fit to cool off--remembering that sweet good yeast, clean sweet hogsheads, with this mode of mashing carefully, will produce you a good turn out of your grain. The quantity of corn and rye is generally two stroked half bushels of each, and one gallon malt. ART. V. _To Mash one third Rye and two thirds Corn._ This I deem the most profitable mashing that a distiller can work, and if he can get completely in the way of working corn and rye in this proportion, he will find it the easiest process of mashing. That corn has as much and as good whiskey as rye or any other grain, cannot be disputed, and the slop or pot ale is much superior to that of any other grain, for feeding or fattening either horned cattle or hogs--one gallon of corn pot ale being esteemed worth three of rye, and cattle will always eat it better--and moreover, corn is always from one to two shillings per bushel cheaper than rye, and in many places much plentier--so that by adopting this method and performing it well, the distiller will find at the close of the year, it has advantages over all other processes and mixtures of rye and corn, yielding more profit, and sustaining the flock better. Hogs fatted on this pot ale, will be found decidedly better than any fatted on the slops of any other kind of mashing. _Mash as follows._ Have sweet hogsheads, good yeast and clean water in your boiler; when the water is sharp, warm, or half boiling, put into every hogshead you mean to mash at the same time, six, eight or as many gallons of the half boiling water, as will completely wet one bushel corn meal--add then one bushel chopped corn, stir it with your mashing stick till your corn is all wet; it is better to put in a less quantity of water first, and so add as you may find necessary, until completely wet (be careful in all mashings, that your mashing stick be clean), this is called soaking the corn. Then fill up your boiler, bring her quickly to a boil, when effectually boiling, put into every hogshead, twelve gallons boiling water, stirring it well after putting in each bucket, until the lumps are quite broken--cover the hogsheads close, after a complete stirring--fill up your boiler, bring her quickly to boil for the last mashing--stir the corn in the hogshead every fifteen minutes, till your last water is boiling--put into each hogshead one pint salt, and a shovel full of red hot coals, stirring it well--then put in each hogshead sixteen gallons of boiling water, stir it well--cover it close for twenty-five minutes--then put into each hogshead one half bushel rye meal, and one gallon good chopped malt, stirring it until the lumps are all broken, then cover it close, stir it every half hour, until you perceive it sufficiently scalded--then uncover it and stir it as often as your other business will permit, until ready to cool off. In this and every other mashing you must use sweet vessels only and good yeast, or your labor will be in vain; and in all kinds of mashing you cannot stir too much. ART. VI. _To Mash Corn._ This is an unprofitable and unproductive mode of mashing, but there may be some times when the distiller is out of rye, on account of the mill being stopped, bad roads, bad weather, or some other cause; and to avoid the necessity of feeding raw grain to the hogs or cattle, (presuming every distillery to be depended on for supplying a stock of some kind, and often as a great reliance for a large stock of cattle and hogs,) in cold weather I have found it answer very well, but in warm weather it will not do. Those who may be compelled then from the above causes, or led to it by fancy, may try the following method. To one hogshead, put twelve gallons boiling water, and one and an half bushels corn, stir it well, then when your water boils, add twelve gallons more, (boiling hot,) stir it well, and cover it close, until the still boils the third time, then put in each hogshead, one quart of salt, and sixteen gallons boiling water, stir it effectually, cover it close until you perceive it nearly scalded enough, then put in two, or three gallons cold water, (as you will find to answer best,) and two gallons malt, or more if it can be spared--stir it well, then cover it for half an hour, then uncover and stir it well, until cold enough to cool off. ART. VII. _To make four gallons from the bushel._ This is a method of mashing that I much approve of, and recommend to all whiskey distillers to try it--it is easy in process, and is very little more trouble than the common method, and may be done in every way of mashing, as well with corn or rye, as also a mixture of each, for eight months in the year; and for the other four is worth the trouble of following. I do not mean to say that the quantity of four gallons can be made at an average, in every distillery, with every sort of grain, and water, or during every vicissitude of weather, and by every distiller, but this far I will venture to say, that a still house that is kept in complete order, with good water, grain well chopped, good malt, hops, and above all good yeast; together with an apt, careful and industrious distiller, cannot fail to produce at an average for eight months in the year, three and three quarter gallons from the bushel at a moderate calculation. I have known it sometimes produce four and an half gallons to the bushel, for two or three days, and sometimes for as many weeks, when perhaps, the third or fourth day, or week, it would scarcely yield three gallons; a change we must account for, in a change of weather, the water or the neglect or ignorance of the distiller. For instance, we know that four gallons of whiskey is in the bushel of rye or corn--certain, that this quantity has been made from the bushel; then why not always? Because, is the answer, there is something wrong, sour yeast or hogsheads, neglect of duty in the distiller, change of grain, or change of weather--then of course it is the duty of the distiller to guard against all these causes as near as he can. The following method, if it does not produce in every distillery the quantity above mentioned, will certainly produce more whiskey from the bushel, than any other mode I have ever known pursued. Mash your grain in the method that you find will yield you most whiskey--the day before you intend mashing, have a clean hogshead set in a convenient part of the distillery; when your singling still is run off, take the head off and fill her up with clean water, let her stand half an hour, to let the thick part settle to the bottom, which it will do when settled, dip out with a gallon or pail, and fill the clean hogshead half full, let the hogshead stand until it cools a little, so that when you fill it up with cool water, it will be about milk-warm, then yeast it off with the yeast for making 4 gallons to the bushel, then cover it close, and let it work or ferment until the day following, when you are going to cool off; when the cold water is running into your hogshead of mashed stuff, take the one third of this hogshead to every hogshead, (the above being calculated for three hogsheads) to be mashed every day, stirring the hogsheads well before you yeast them off. This process is simple, and I flatter myself will be found worthy of the trouble. ART. VIII. _To know when Grain is scalded enough._ Put your mashing stick into your hogshead and stir it round two or three times gently, then lift it out and give it a gentle stroke on the edge of your hogshead--if you perceive the batter or musky part fall off your stick, and there remains the heart of the grain on your mashing stick, like grains of timothy seed, then be assured that it is sufficiently scalded, if not too much, this hint will suffice to the new beginner, but experience and observation will enable the most correct judgment. ART. IX. _Directions for cooling off._ Much observation is necessary to enable the distiller to cool off with judgment--which necessity is increased by the versatility of our climate, the seasons of the year, and the kinds of water used. These circumstances prevent a strict adherence to any particular or specific mode; I however submit a few observations for the guidance of distillers in this branch.--If in summer you go to cool off with cold spring water, then of course the mashed stuff in your hogsheads must be much warmer, than if you intended cooling off with creek or river water, both of which are generally near milk warm, which is the proper heat for cooling off--In summer a little cooler, and in winter a little warmer. It will be found that a hogshead of mashed grain will always get warmer, after it begins to work or ferment. When the mashed stuff in your hogsheads is brought to a certain degree of heat, by stirring, which in summer will feel sharp warm, or so warm, that you can hardly bear your hand in it for any length of time, will do for common water, but for very cold or very warm water to cool off with, the stuff in the hogsheads must be left colder or warmer, as the distiller may think most expedient, or to best suit the cooling off water. When you think it is time to cool off, have a trough or conveyance to bring the water to your hogsheads ready--let the hogsheads be well stirred, then let the water run into them slowly, stirring them all the time the water is running in, until they are milk warm, then stop the water, and after stirring them perfectly, put in the yeast and stir it until completely incorporated with the mashed stuff, then cover your hogshead until it begins to ferment or work, then uncover it. ART. X. _To ascertain when Rye works well in the Hogshead._ When mashed rye begins to work or ferment in the hogsheads, either in a heavy, thick, or light bubbly top, both of which are unfavorable; when it rises in a thick heavy top, you may be sure there is something wrong, either in the grain, yeast, or cooling off. When the top (as called by distillers) appear, with bubbles about the size of a nutmeg, rising and falling alternately, with the top not too thick nor too thin, and with the appearance of waves, mixed with the grain in the hogshead, rising and falling in succession, and when you put your head over the steam, and it flying into your nose, will have a suffocating effect, or when it will instantly extinguish a candle when held over it, you may feel assured, it is working well. From these hints and the experience of the distiller, a judgment may be formed of the state of fermentation and the quality. ART. XI. _To prevent Hogsheads from working over._ If the stuff is cooled off too warm, or too much yeast is put in the hogsheads, they will work over, and of course lose a great deal of spirit, to prevent which, take tallow and rub round the chine of the hogsheads a little higher than they ought to work; it will generally prevent them from rising any higher, but if they will work over in spite of this remedy, then drop a little tallow into the stuff, it will immediately sink the stuff to a proper height. SECTION IV. ARTICLE I. _Observations on the quality of Rye for distilling._ The best rye for distilling is that which is thoroughly ripe, before it is cut, and kept dry till threshed; if it has grown on high or hilly ground, it is therefore to be preferred, being then sounder and the grain fuller, than that produced on low level land--but very often the distiller has no choice, but must take that which is most convenient;--great care however ought to be observed in selecting sound rye, that has been kept dry, is clean and free from cockle, and all kind of dirt, advantages will result from fanning it, or running it through a windmill before it is chopped. ART. II. _Mode of chopping Rye and the proper size._ The mill stones ought to be burrs, and kept very sharp for chopping rye for distillation; and the miller ought to be careful not to draw more water on the wheel than just sufficient to do it well, and avoid feeding the stones plentifully; because in drawing a plentiful supply of water, the wheel will compel a too rapid movement of the stones, of course render it necessary they should be more abundantly fed, which causes part to be ground dead, or too fine, whilst part thereof will be too coarse, and not sufficiently broken, so that a difficulty arises in scalding--for in this state it will not scald equally, and of consequence, the fermentation cannot be so good or regular; and moreover as part of it will merely be flattened, a greater difficulty will arise in breaking the lumps, when you mash and stir your hogsheads. If burr stones are very sharp, I recommend the rye to be chopped very fine, but to guard against over-seeding, or pressing too much on them; but if the stones are not sharp, I would recommend the rye should be chopped about half fine. Distillers in general sustain a loss from having their rye chopped so coarse as I have observed it done in common. ART. III. _Chopping or Grinding Indian Corn._ Indian corn cannot be ground too fine for distilling. ART. IV. _Malt_ Cannot be ground too coarse, provided it is done even--there ought to be no fine nor coarse grains in malt, but ground perfectly alike, and of the same grade. If ground too fine, it will be apt to be scalded too much in mashing. Malt does not require half the scalding necessary in rye. Let the distiller try the experiment of coarse and then of fine ground malt and judge for himself. ART. V. _How to choose Malt._ Malt is chosen by its sweet smell, mellow taste, full flower, round body and thin skin. There are two kinds used, the pale and the brown--the pale is the best. ART. VI. _How to build a Malt kiln in every Distillery._ When setting up your stills, leave a space of about nine inches for a small furnace between the large ones, extend it to your chimney and carry up a funnel, there-from to the loft, then stop it--here build the kiln on the loft, about 4 or 5 feet square, the walls to be composed of single brick, 3 feet high--lay the bottom with brick, cover it with a plaster of mortar, to prevent the floor from taking fire. Turn the funnel of the chimney into, and extend it to the centre of the kiln, cover the top, leaving vent holes at the sides for the heat to escape thro'--Place on the top of the kiln, sheet iron or tin punched full of small holes, too small to admit the passage of malt; lay the malt on the top of the tin, when ready for drying. Put coals from under the still furnace into the small furnace leading to the kiln, which will heat the kiln and dry the malt above, by adding to or diminishing the quantity of coals, the heat may be increased or decreased, as may be found necessary. Malt for distilling ought to be dried without smoke. ART. VII. _Hops._ Give a preference to hops of a bright green colour, sweet smell, and have a gummy or clammy effect when rubbed between the hands or fingers. SECTION V. ARTICLE I. _How to order and fill the Singling still when distilling Rye._ Scrape, clean, and grease the singling still, fill her up with beer, and keep a good fire under her, till she be warm enough to head, stirring her constantly with a broom, to prevent the grain from sticking to the bottom or sides, and burning, which it is very apt to do when the beer is cold, but when it comes to boil there is little danger, prevented by the motion of boiling; have the head washed clean--when she is ready for the head, clap it on and paste it; keep up a brisk fire, until she begins to drop from the worm, then put in the damper in the chimney, and if the fire be very strong, moderate it a little, by throwing ashes or water on it, to prevent her throwing the head, which she will be very apt to do if very full, and coming round under a strong fire, (should the head come, or be thrown off, the spirit remaining will scarcely be worth running off). When fairly round and running moderately, watch her for half an hour; after which, unless the fire is very strong all danger is over. Should she happen to throw the head, it is the duty of the distiller to take and (wash the head and worm--the latter will be found full of stuff) clean, clap on the head, and paste it--but the moment the head is thrown off, the fire should be drowned out, and water thrown into the still to prevent her boiling over. It is important that after every run, or rather before you commence a run, the distiller should carefully clean out the still, wipe the bottom dry, and grease her well, to prevent her from burning and singeing the liquor. ART. II. _Mode of managing the doubling Still when making Whiskey._ Let the doubling still be carefully cleaned and washed out, then be filled with singlings and low wines left from the run preceding, add thereto half a pint of salt and one quart of clean ashes, which will help to clear the whiskey, and a handful of Indian meal to prevent the still from leaking at the cock, or elsewhere--clean the head and worm, put on the head, paste it well; put fire under and bring her round slowly, and run the spirit off as slow as possible, and preserve the water in the cooling tub as cold as in your power. Let the liquor as it runs from the worm pass thro' a flannel to prevent the overjuice from the copper, and the oil of the grain from mixing with the spirit. The first being poisonous, and the latter injurious to the liquor. The doubling still cannot be run too slow for making good whiskey ... observe when the proof leaves the worm, that is when there is no proof on the liquor as it comes from the worm, if there be ten gallons in your doubling keg, if so, run out three more, which will make in all thirteen gallons first proof whiskey. If the proof leaves the worm at eight gallons, then run till eleven gallons and so on in proportion, to the larger or smaller quantity in your keg at the time of the ceasing of the proof. ART. III. _Observations on the advantages of making strong and good Whiskey with stalement, &c._ The distiller who makes whiskey for a market under the government of inspection laws, too weak, sustains a loss of a cent for each degree it may be under proof ... and the disadvantages are increased in proportion to the extent of land carriage. If a distance of seventy miles, the price of carriage per gallon will be about six cents, paying the same price for weak or strong ... not only the disadvantage of paying for the carriage of feints or water, but the loss in the casks, which tho' small apparently at first view, yet if nicely attended to, will amount in the course of the year to a sum of moment to every distiller or proprietor. To convey my ideas, or render a more compleat exposition of my impressions as to the actual loss on one waggon load (predicated on a distance of seventy miles land carriage) of first proof whiskey, and that nine degrees under proof. I give the following statement. 300 _gallons good first proof whiskey at_ 50 _cents_, $ 150 _haling at six cents_, 18 ________ $ 132 00 300 _gallons whiskey nine degrees under proof at_ 41 _cents_, $ 123 _haling_ 18 ________ $ 105 00 ________ difference $ 27 00 This difference of twenty-seven dollars in favor of the distiller, who sends first proof whiskey, is not the only advantage, but he saves in barrels or casks, what will contain fifty four gallons, nearly two barrels; which together with the time saved, or gained in running good whiskey only, of filling and measuring it out, loading, &c. will leave an advantage of I presume, three dollars in each load. Or to verify more satisfactorily, and I hope my readers will not think me too prolix, as economy cannot be too much attended to in this business, I add a statement predicated on a year's work, and on the foregoing principles: _The distiller of weak whiskey, in twelve months, or one year, distils at the rate of_ 100 _gallons per week, or say in the year, he prepares for a market at the above distance,_ 5000 _gallons, which ought to command_ $ 2,500 _But he sustains a loss or deduction of_ 9 _cents_, 450 _Then the first loss may safely be computed at_ $ 450 150 _empty barrels necessary to contain_ 5000 _gallons, at_ 33-1/3 _gallons to the barrel, estimating the barrel at 7s and 6d, is_ $ 150 _This quantity of whiskey, when reduced to proof, is 4,100 gals. which would have occupied only 123 barrels_, 123 ------- 27 _Then the second loss may be estimated at_ $ 27 _He ought to have made this quantity of_ 4100 _gallons in nine months and three weeks, but we will say 10 months, sustaining a loss of two months in the year._ _3d item of loss. Hire of distiller for 2 months at_ $12 24 00 _4th do. Rent of distillery do. at £15 per annum._ 6 66 _5th do. One sixth of the wood consumed, (at the rate of 100 cords per annum,) 16 cords_, 20 00 _6th do. One sixth of the Malt, do. say 90 bushels_, 90 00 _7th do. Is the wear and tear of stills, vessels, &c._ 12 34 ------- $ 630 Showing hereby a total annual loss to the careless distiller, of six hundred and thirty dollars, and a weekly loss of twelve dollars and three cents in the whiskey of nine degrees below proof--our ninth part of which is seventy dollars, which is the sum of loss sustained on each degree in this quantity of whiskey. The foregoing I flatter myself will not only show the necessity of care, cleanliness, industry and judgment, in the business of distilling; a business professed to be known, by almost every body--but in reality quite a science, and so abstruse as to be but too imperfectly understood; and moreover, the value of time, so inestimable in itself, the economy of which is so rarely attended to. ART. IV. _Distilling of Buckwheat._ Buckwheat is an unprofitable grain for the distillers when distilled by itself, but when mixed with rye, it will yield nearly as much as rye; but I would by no means recommend the use of it when it can be avoided. Tho' sometimes necessity requires that a distiller should mash it for a day or two, when any thing is the matter, or that grain cannot be procured. In such event, the directions for distilling rye, or rye and corn may be followed, but it requires a much larger quantity of boiling water and if distilled by itself; it is necessary some wheat bran be mixed with it to raise it to the top of the hogshead: but by no means use buckwheat meal in making yeast. ART. V. _Distilling of Potatoes._ This is a branch of distilling that I cannot too highly recommend to the attention of every American--nor can the cultivation of this valuable vegetable be carried to a too great extent, the value of which ought to be known to every planter and it some times has awakened my surprise that they are not more cultivated, as it is notorious that they will sustain, and be a tolerable food for every thing possessing life on this earth--and as they produce a brandy, if properly made, of fine flavour. I hope yet to see the day when it will take precedence of French brandy and West-India spirits, and thereby retain in our own country, the immense sums at present expended on those foreign liquors; which, tho' benefitted by the sea voyage, yet often reaches us in a most pernicious state, and is frequently adulterated here. Could the American farmer be brought to raise a larger quantity of potatoes than necessary for his consumption at home, the price would be lowered, and the distiller might commence the distillation of them with greater propriety. That they contain a great deal and a very good spirit, I am certain, and moreover, after distillation will yield as great a quantity of good wholesome food for cattle or hogs, as rye or any other grain. If distillers could be brought to try the experiment of distilling ten or twelve bushels annually, I venture to predict that it would soon become a source of profit to themselves, encouragement to the farmer, and be of benefit to our country at large. One acre of ground, if well farmed, will produce from fifty to one hundred bushels of potatoes, but say sixty on an average. One hundred farmers each planting one acre, would yield six thousand bushels, which will yield at least two gallons of spirit to each bushel; thus, twelve thousand gallons of wholesome spirit may be produced, and with care, as good as necessary to be drank. Each farmer proceeding in this way, would have one hundred and twenty gallons spirit, as much as he may have occasion to use in the year, which would save the price of some acres of wheat or one hundred and twenty gallons rye whiskey. Each acre worked in potatoes will be in better order to receive a crop of wheat, barley, rye, or any kind of grain, than from any other culture. The farmer often receiving the advantage of a double crop, at the expense of seed and labor. They grow equally well in every soil and climate, in poor as well as rich ground--provided the thin soil be manured, and the potatoes plastered with plaster of Paris; and moreover, they are easier prepared for distilling than either apples, rye or corn, as I shall show hereafter when I come to treat of the mode of preparation; and in order to demonstrate the advantages that would arise to the farmer and distiller; I add a statement of the probable profits of ten acres of potatoes, and that of a like number of acres of rye, to shew which offers the greatest advantages. _Potatoes_ DR. _Ten acres at_ 60 _bushels is_ 600 _bushels at_ 33 _cents_ $ 198 00 _Rye._ _Ten acres of Rye, at_ 30 _bushels per acre, is_ 300 _bushels at_ 60 _cents_ $ 180 00 CR. 600 _bushels yielding_ 2 _gallons to the bushel,_ 1200 _gallons at_ 50 _cents_ 600 ----- $ 402 CR. 300 _bushels yielding_ 3 _gallons to the bushel_, 900 _gallons at_ 50 _cents_ 450 ----- $ 270 _Balance in favor of Potatoes_ $ 132 Thus a balance of one hundred and thirty two dollars would appear in favor of the yield of potatoes. I would not pretend to say that ten acres of Potatoes will not take more labor than ten acres of rye, but this far I will venture to say, that the profits arising from the sale of this brandy, will more than double pay the additional expense of raising them, besides the ground will be in much better condition to receive a crop of wheat, than the rye ground, nay, will be enriched from the crop, whilst the rye ground will be greatly impoverished. ART. VI. _Receipt to prepare Potatoes for Distilling._ Wash them clean, and grind them in an apple mill, and if there be no apple mill convenient, they may be scalded and then pounded--then put two or three bushels into a hogshead and fill the hogshead nearly full of boiling water, and stir it well for half an hour, then cover it close until the potatoes are scalded quite soft, then stir them often until they are quite cold--then put into each hogshead about two quarts of good yeast and let them ferment, which will require eight or ten days--the beer then may be drawn off and distilled, or put the pulp and all into the still, and distill them as you do apples. I have known potatoes distilled in this way to yield upwards of three gallons to the bushel. ART. VII. _Pumpions_ May be prepared by the same process used in preparing potatoes, with the exception of not scalding them so high, nor do they require so much yeast. ART. VIII. _Turnips_ Will produce nearly as much spirit as potatoes, but not so good. They must be prepared in the same manner. ART. IX. _How to distil Apples._ Apples ought to be perfectly ripe for distillation, as it has been ascertained from repeated trials, that they produce more and better spirit, (as well as cider), when fully ripe than if taken green, or the ripe and unripe mixed--if taken mixed it will not be found practicable to grind them evenly, or equally fine; those fully ripe will be well ground, whilst those hard and unripe will be little more than broken or slightly bruised--and when this coarse and fine mixture is put into a hogshead to work or ferment, that fully ripe and fine ground, will immediately begin, and will be nearly if not quite done working before the other begins, and of course nearly all the spirit contained in the unripe fruit will be lost--and if it is left standing until the ill ground unripe fruit is thoroughly fermented, and done working, you will perceive that a large portion of the spirit contained in the ripe well ground fruit is evaporated and of course lost. But if the fruit be all ripe and evenly ground, of course then it will work regularly and can be distilled in due and right order, and will produce the greatest quantity of spirit, and much superior to that produced from uneven, ill-ground or unripe fruit. Apples cannot be ground too fine. ART. X. _How to order Apples in the Hogsheads._ When the apples are ground put them into open hogsheads to ferment, taking care not to fill them too full, or they will work over; set them under cover, as the sun will sour them too soon, if permitted to operate on them, and by his heat extract a considerable quantity of the spirit, if the weather be warm they will work fast enough, provided you have a sufficient supply of hogsheads to keep your stills agoing in due time and order; about twenty hogsheads are sufficient to keep one singling still of one hundred and ten gallons agoing, if you distil the pumice with the juice, but if you press off the apples after they are done working, you must have three times that number. In warm weather five or six days is long enough for apples to work, as it is always better to distil them before they are quite done working, then to let them stand one hour after the fermentation ceases. ART. XI. _How to work Apples slow or fast._ If the hogsheads ripens too fast for your stills, add every day to each hogshead four gallons cold spring water, putting it into a hole made in the centre of the apples, with a large round stick of wood; by thus putting it into the centre of the hogshead, it will chill the fermentation, and thereby prevent the fruit from becoming ripe sooner than it may suit the convenience of the distiller. But I think it advisable that distillers should take in no more apples than they can properly manage in due time. If the weather be cold, and the apples do not ripen so fast as you wish, then add every twelve hours, four gallons boiling, or warm water, which will ripen them if the weather be not too cold in four days at farthest. ART. XII. _How to judge when Apples are ready for distilling._ Put your hand down into the hogsheads amongst the apples as far as you can, and bring out a handful of pugs--squeeze them in your hand, through your fingers, observe if there be any core, or lumps of apples un-digested, if none, you may consider them as sufficiently fermented and quite ready for distilling. It may also be ascertained by tasting and smelling the cider or juice, which rises in the hole placed in the centre; if it tastes sweet and smells strong, it is not yet ready, but when quite fermented, the taste will be sour, and smell strong, which is the proper taste for distilling. A nice discriminating attention is necessary to ascertain precisely, when the fermentation ceases, which is the proper moment for distillation, and I would recommend, rather to anticipate, than delay one hour after this period. ART. XIII. _How to fill and order the singling Still, when running Apple singlings._ When you perceive your apples ready for distilling, fill the singling still with apples and water; using about half a hogshead apples in a still of 110 gallons, the residue water, first having cleaned the still well, and greased her previous to filling--put fire under her and bring her ready to head, as quick as possible, stirring the contents well with a broom until ready to head, of which you can judge by the warmth of the apples and water, which must be rather warm to bear your hand in it any length of time. Wash the still head and worm clean, put on the head, paste it, keeping a good fire until she runs at the worm; run off 14 gallons briskly, and catch the feints in a bucket to throw into the next still full, if the singling still too fast, provided she does not smoke at the worm. When the first still full is off, and before you go to fill her the second time, draw or spread the coals that may be under her, in the furnace, and fill the furnace with wood. Shut up your furnace door and put in your damper; by proceeding thus, you cool the still and avoid burning her; this plan I deem preferable to watering out the fire. When empty, rinse the still round with cold water, scrape and grease her, then she will be ready to receive a second charge. Care is necessary in scraping and greasing your still every time she is emptied, if this is neglected, the brandy may be burnt and the still injured. ART. XIV. _How to double Apple Brandy._ Fill the doubling still with singlings, and add a quart of lime, (which will clear it) put fire under her and bring her to a run briskly--after she runs, lessen the fire and run her as slow as possible. Slow running will prevent any of the spirit from escaping, and make more and better brandy, than fast running.--Let the liquor filter thro a flannel cloth from the worm. ART. XV. _How to prepare Peaches._ Peaches like apples ought to be equally ripe, in order to insure an equal and regular fermentation--for where ripe and unripe fruit are thrown into the same hogshead, and ordered for distillation in this way a disadvantage is sustained. I therefore recommend to farmers and distillers, when picking the peaches to assort them when putting them in hogsheads, all soft ripe peaches may go together, as also those which are hard and less ripe--this will enable a more regular fermentation, and though the hard and less ripe, will take a longer time, than the soft and ripe to ferment, and yield less, yet the disadvantage will not be so great, as if mixed. They ought to be ground in a mill with metal nuts, that the stone and kernel may be well broken. The kernel when thus broken will give a finer flavor to the brandy, and increase the quantity. When they are ground they must be placed in hogsheads and worked in the same way with apples, but distilled sooner or they will lose much more spirit by standing any time after fermentation than apples. It is therefore better to distil them a short time before they are done working than at any period after. ART. XVI. _How to double and single Peach Brandy._ The same process must be observed in running off peaches as in apples, except that the singling still ought not to be run so fast, nor so much fire kept under her, and more water used to prevent burning. SECTION VI. ARTICLE I. _The best method of setting Stills._ If stills are not set right, great injury may accrue to them, in burning and damaging the sides, singeing the whiskey, and wasting of fuel too, are not the only disadvantages; but more damage may be done in six months, than would pay a man of judgment for putting up twenty pair. If they are set with their bottoms to the fire, they are very apt to burn, without the utmost care of the distiller, in stirring her when newly filled with cold beer, until she is warm, and by previously greasing the bottom well when empty. If wood be plenty, stills ought to be set on an arch, but if scarce, the bottom ought to be set to the fire. The following method is calculated for a furnace of either two or four feet long, and with the bottoms exposed, or on an arch as the distiller may fancy. Make up a quantity of well worked mortar, composed of the greater proportion of good clay, a little lime and cut straw. Lay the bottom of the furnace with flag stones, or good brick, from two to four feet long, as may be deemed most proper, let it be from twelve to sixteen inches wide, and from twelve to fourteen high. Then if it is designed to turn an arch, set the end of a brick on each wall of the furnace, leaning them over the furnace, till they meet in the middle--so continue the range on each side, until the furnace is completely covered in, leaving a small hole for the flue leading to the chimney behind, leaning towards the side, from which the flue is to be started, to proceed round the bilge of the still, which passage must be ten by four inches wide. After completing the arch as described, lay thereon a complete bed of mortar, well mixed with cut straw, set the still thereon, levelling her so that she will nearly empty her self by the stoop towards the cock; then fill up all round her with mortar to the lower rivets, carefully preventing any stone or brick from touching her, (as they would tend to burn her) ... then build the fender or fenders; being a wall composed of brickbats and clay well mixed with cut straw, build it from the commencement of the flue, and continue it about half round the still ... this is to prevent the flames from striking the still sides, in its hot state, immediately after it leaves the furnace, presuming that it will terminate before it reaches the end of this little wall or fender, between which, and the still, a space of two inches ought to be left for the action of the heat, which space preserves, and prevents the wall or fender, from burning the still; the mode in common practice, being to place it against the still, which will certainly singe or burn her. When this defender is finished, commence a wall, which continue round, laying a brick for a foundation, about four inches from the lower rivets; thus raising this wall for the flue, continuing it at an equal distance from the still, leaving a concave to correspond with the bilge of the still, and to be of precisely the same width and height all round the still. This precaution is absolutely necessary in building the wall of the flue exactly to correspond with the form of the still, and equally distant all round, for reasons 1st. The fire acts with equal force on every part of the still, and a greater heat may be applied to her, without burning. 2d. It has a great tendency to prevent the still house from smoking. When the wall of the flue is completed round the still, and raised so high, that a brick when laid on the top of the wall will extend to the rivets in the breast of the still or upper rivets, then completely plaster very smooth and even, the inside of the flue, and then cover the flue with a layer of brick, with a slight fall, or leaning a little from the still outwards, so that if water were dropped thereon, it would run off outwardly, carefully laying a layer of clay on the top of the wall, on which the brick may rest, and thereby prevent the brick from burning the still; carefully forming the brick with the trowel, so as to fit the wall and rest more safely--cautiously covering them well with clay, &c. and closing every crevice or aperture, to prevent smoak from coming thro' or the heat from deserting the flue till it passes to the chimney from the flue; then fill the still with water, and put a flow fire under her to dry the work. When the wall begins to dry, lay on a coat of mortar, (such as the next receipt directs), about two inches thick, when this begins to dry, lay a white coat of lime and sand-mortar, smoothing well with a trowel; rubbing it constantly and pressing it severely with the trowel to prevent it from cracking. There are many modes of setting stills and bringing the fire up by flues variously constructed, but I have found the foregoing plan to afford as great a saving of fuel, and bringing the still to a boil as early as any other. ART. II. _How to prevent the Plastering round Stills from cracking._ This method of making water proof plastering on stills, is done entirely in making the mortar, and putting it on, in making which, good clay and lime are absolutely necessary. When the mortar for the first coat is thoroughly worked, put as much brock of rye straw into it, as can be worked in, so that when the coat is put on, it may have a greater appearance of straw than mortar, when dry, and covered with the second coat composed of lime mortar, well rubbed and pressed with the trowel until it be dry. A covering put on of those materials, will be found to continue firm and compact without cracking, as in the common mode. _The best method of boiling two, three or more Stills or Kettles with one fire or furnace._ This method has been found to answer in some instances, and may perhaps do generally if properly managed. I will here give the result of my own experiments. I set a singling still holding 180 gallons on a furnace of 18 by 14 inches, and 4 feet six inches long, with the bottom to the fire, she had a common head and worm with scrapers and chains in her. I extended the flue, (or after passing it round her), to the doubling still which it likewise went round--but to prevent too much heat from passing to the doubling still, I fixed a shutter in the flue of the singling still, immediately above the intersection of the flue of the doubling still, to turn all the heat round her, and another shutter in the flue of the doubling still at the intersection of the flue of the singling still, to shut the heat off from the doubling still if necessary. With this fixture I run six hogsheads off in every twenty four hours and doubled the same, with the same heat and fire. I likewise had a boiler under which I kept another fire, which two fires consumed about three cords and an half of wood per week, distilling at the rate of sixty-five bushels of grain per week, and making about one hundred and ninety gallons in the same time. Before I adopted this method I kept four fires agoing, and made about the same quantity of whiskey, consuming about four and an half cords of wood per week, and was obliged to have the assistance of an additional distiller per week. I have since heard of the adoption of this plan with more success than I experienced. ART. III. _To set a doubling Still._ As spirits can hardly be burned or singed in a doubling still, if not before done in singling, all the precaution necessary is to set them in the best method for saving fuel, and preserving the still. The instructions given for setting a singling still, is presumed to be adequate to setting a doubling still. _How to prevent the singling Still from burning._ If the singling still be well set, and is carefully greased with a piece of bacon, tallow or hard soap, every time she is filled, she will seldom burn, but if she does burn or singe notwithstanding these precautions, it will be advisable to take her down and set her up a new ten times, rather than have her burned. SECTION VII. ARTICLE I. _How to clarify Whiskey, &c._ Take any vessel of convenient size, take one end out and make it clean, by scalding or otherwise; bore the bottom full of holes, a quarter of an inch in diameter--lay thereon three folds of flannel, over which spread ground maple charcoal and burnt brick-dust, made to the consistence of mortar, with whiskey, about two inches thick, pour your whiskey or brandy thereon, and let it filter thro' the charcoal, flannel, &c. after which you will find the spirit to have scarcely any taste or smell of whiskey.--Elevate the filtering cask so as to leave room to place a vessel to receive the spirit under it. ART. II. _How to make a Brandy resembling French Brandy, from Rye Whiskey or Apple Brandy._ Clarify the whiskey as the above receipt directs, after thus purifying, add one third or one fourth of French brandy, and it will be then found strongly to resemble the French brandy in taste and smell--and if kept a few years, will be found more salutary and healthful than French brandy alone. This mode of clarifying rids the spirit of any unpleasant flavour received in the process of distillation or from bad materials, and moreover, from all those vicious, poisonous properties contracted in the still or worm from copper; such as foetid oil from the malt, which frequently unites with the verdigris, and combines so effectually with whiskey, that it may possible require a frequent repetition of this mode of clarifying, to rid it completely of any unpleasant taste or property contracted as above stated. ART. III. _How to make a Spirit resemble Jamaica Spirit out of Rye Whiskey._ This is done precisely in the manner laid down in the receipt for French brandy. ART. IV. _How to make a resemblance of Holland Gin out of Rye Whiskey._ Put clarified whiskey, with an equal quantity of water, into your doubling still, together with a sufficient quantity of juniper berries, prepared; take a pound of unflacked lime, immerse it in three pints of water, stir it well--then let it stand three hours, until the lime sinks to the bottom, then pour off the clear lime water, with which boil half an ounce of isinglass cut small, until the latter is dissolved--then pour it into your doubling still with a handful of hops, and a handful of common salt, put on the head and set her a running; when she begins to run, take the first half gallon (which is not so good), and reserve it for the next still you fill--as the first shot generally contains something that will give an unpleasant taste and colour to the gin. When it looses proof at the worm, take the keg away that contains the gin, and bring it down to a proper strength with rain water, which must previously have been prepared, by having been evaporated and condensed in the doubling still and cooling tub. This gin when fined, and two years old, will be equal, if not superior to Holland gin. The isinglass, lime water and salt, helps to refine it in the still, and the juniper berries gives the flavor or taste of Holland gin. About thirteen pounds of good berries, are sufficient for one barrel. Be careful to let the gin as it runs from the worm, pass thro' a flannel cloth, which will prevent many unpleasant particles from passing into the liquor, which are contracted in the condensation, and the overjuice imbibed in its passage thro' the worm. ART. V. _The best method of making common country Gin._ Take of singlings a sufficient quantity to fill the doubling still, put therein ten or twelve pounds of juniper berries, with one shovel full of ashes, and two ounces alum--put on the bead, and run her off, as is done in making whiskey. This is the common mode of making country gin; but is in this state little superior to whiskey, save as to smell and flavor. It is therefore in my mind, that the mode of clarifying, prescribed, ought to be pursued in all distilleries, so far as necessary to make a sufficient quantity of good spirit for any market convenient--the supply of respectable neighbors, who may prefer giving a trifle more per gallon, than for common stuff and for domestic use. And moreover, I think the distiller will meet a generous price for such clarified, and pure spirit, as he may send to a large mercantile town for sale--as brewers and others, frequently desire such for mixing, brewing, making brandies in the French and Spanish mode, and spirits after the Jamaica custom. And after the establishment of a filtering tub or hopper, prepared as before described, with holes, flannel or woollen cloth, and plenty of maple charcoal, and burnt brick-dust, a distiller may always find leisure to attend to the filtration; indeed it will be found as simple and easy, as the process for making ley from ashes in the country for soap. But I would suggest that spirit prepared and clarified in this way, should be put into the sweetest and perfectly pure casks. New barrels will most certainly impart color, and perhaps some taste, which would injure the sale, if intended for a commercial town market, and for brewing, or mixing with spirits, from which it is to receive its flavor. For my own use, I would put this spirit into a nice sweet cask, and to each barrel I would add a pint of regularly, and well browned wheat, not burned but roasted as much as coffee. The taste of peach brandy may be imparted to it by a quantity of peach stone kernels, dried, pounded and stirred into the cask; in this way, those who are fond of the peach brandy flavor, may drink it without becoming subject to the pernicious consequences that arise from the constant use of peach brandy. Peach brandy, unless cleansed of its gross and cloying properties, or is suffered to acquire some years of age, has a cloying effect on the stomach, which it vitiates, by destroying the effect of the salival and gastric juices, which have an effect on aliment, similar to that of yeast on bread, and by its singular properties prevents those juices from the performance of their usual functions in the fermentation of the food taken into the stomach--producing acid and acrimonious matter, which in warm climates generates fevers and agues. Apple brandy has not quite a similar but equally pernicious effect, which age generally removes--indeed, age renders it a very fine liquor, and when diluted with water, makes a very happy beverage, gives life and animation to the digesting powers, and rarely leaves the stomach heavy, languid and cloyed. Then both those, (indeed, all liquors,) ought to be avoided when new, by persons of delicate habit, and those who do not exercise freely. A severe exercise and rough life, generally enables the stomach to digest the most coarse food, by liquor, however new. _On fining Liquors._ Isinglass is almost universally used in fining liquors. Take about half an ounce to the barrel--beat it fine with a hammer, lay it in a convenient vessel, pour thereon two gallons whiskey, or a like quantity of the liquor you are about to fine, let it soak two or three days, or till it becomes soft enough to mix--then stir it effectually, and add the white and shells of half a dozen eggs--beat them up together and pour them into the cask that is to be fined, then stir it in the cask, bung it slightly, after standing three or four days it will be sufficiently fine, and may be drawn off into a clean cask. ART. VI. _On colouring Liquors._ One pound of brown sugar burnt in a skillet almost to a cinder, add a quart of water, which when stirred, will dissolve the sugar--when dissolved, this quantity will color three barrels. A pint of well parched wheat put into a barrel will colour it, and give more the appearance of a naturally acquired colour, and an aged taste or flavor. ART. VII. _To correct the taste of singed Whiskey._ Altho' this cannot be done effectually without clarifying, as prescribed, but Bohea tea will in a great measure correct a slight singe--a quarter of a pound may be tried to the barrel. ART. VIII. _To give an aged flavor to Whiskey._ This process ought to be attended to by every distiller, and with all whiskey, and if carefully done, would raise the character, and add to the wholesomeness of domestic spirits. It may be done by clarifying the singlings as it runs from the still--let the funnel be a little broader than usual, cover it with two or more layers of flannel, on which place a quantity of finely beaten maple charcoal, thro' which let the singlings filter into your usual receiving cask. When doubling, put some lime and charcoal in the still, and run the liquor thro' a flannel--when it loses proof at the worm, take away the cask, and bring it to proof with rain water that has been distilled. To each hogshead of whiskey, use a pound of Bohea tea, and set it in the sun for two weeks or more, then remove it to a cool cellar, and when cold it will have the taste and flavor of old whiskey. If this method was pursued by distillers and spirits made 2d and 3d proof, it would not only benefit the seller, but would be an advantage to the buyer and consumer--and was any particular distiller to pursue this mode and brand his casks, it would raise the character of his liquor, and give it such an ascendancy as to preclude the sale of any other, beyond what scarcity or an emergency might impel in a commercial city. If distillers could conveniently place their liquor in a high loft, and suffer it to fall to the cellar by a pipe, it would be greatly improved by the friction and ebullition occasioned in the descent and fall. SECTION VIII. ARTICLE I. _Observations on Weather._ Some seasons are better for fermentation than others. Should a hail storm occur in the summer, the distiller should guard against cooling off with water in which hail is dissolved, for it will not work well. If a thundergust happens when the hogsheads are in the highest state of fermentation, the working will nearly cease, and the stuff begin to contract an acidity. And when in the spring the frost is coming out of the ground, it is unfortunate when the distiller is obliged to use water impregnated with the fusions of the frost, such being very injurious to fermentation--Those changes and occurrences ought to be marked well, to enable a provision against their effects. This will be found difficult without the assistance of a barometer, to determine the changes of the weather--a thermometer, to ascertain correctly the heat of the atmosphere, and to enable a medium and temperature of the air to be kept up in the distillery; and from observation to acquire a knowledge of the degree of heat or warmth, in which the mashing in the hogsheads ferments to the greatest advantage, and when this is ascertained, a distiller may in a close house sufficiently ventilated, and provided with convenient windows, always keep up the degree or temperature in the air, most adapted to the promotion of fermentation, by opening his windows or doors to admit air, as a corrective; or by keeping them closed in proportion to the coldness of the weather:--And a hydrometer, useful in measuring and ascertaining the extent of water. Instructions for the management of those instruments generally attend them, it is therefore unnecessary for me to go into a detail on this subject.--But it is absolutely necessary that the careful and scientific distiller should possess them, especially the two former, to guard against the changes of the weather, and preserve the atmosphere in the distillery, always equally warm. ART. II. _Observations on Water._ Distillers cannot be too particular in selecting good water for distilling, when about to erect distilleries. Any water will do for the use of the condensing tubs or coolers, but there are many kinds of water that will not answer the purpose of mashing or fermenting to advantage; among which are snow and limestone water, either of which possess such properties, as to require one fifth more of grain to yield the same quantity of liquor, that would be produced while using river water. Any water will answer the distillers purpose, that will dissolve soap, or will wash well with soap, or make a good lather for shaving. River or creek water is the best for distilling except when mixed with snow or land water from clay or ploughed ground. If no river or creek water can be procured, that from a pond, supplied by a spring, if the bottom be not very muddy will do, as the exposure to the sun, will generally have corrected those properties inimical to fermentation. Very hard water drawn from a deep well, and thrown into a cistern, or reservoir and exposed to the sun and air for two or three days, has been used in mashing with success, with a small addition of chop grain or malt. I consider rain water as next in order to that from the river, for mashing and fermentation. Mountain, slate, gravel and running water, are all preferable to limestone, unless impregnated with minerals--many of which are utterly at variance with fermentation. With few exceptions, I have found limestone, and all spring water too hard for mashing, scalding or fermenting. ART. III. _Precautions against Fire_ Cannot be too closely attended to. The store house, or cellar for keeping whiskey in, ought to be some distance from the distillery, and the liquor deposited, and all work necessary in it done by day, to avoid all possible danger arising from candles or lamps, from which many serious calamities have occurred. Suppose the cellar or place of deposit to be entered at night by a person carrying a lamp or candle, and a leaking cask takes his attention, in correcting the leak, he may set his lamp on the ground covered with whiskey, or he may drop by chance one drop of burning oil on a small stream of whiskey, which will communicate like gun powder, and may cause an explosion, which may in all likelihood destroy the stock on hand, the house, and the life of the individual.--On this subject it is not necessary I should say much, as every individual employed about a distillery must have some knowledge of the value of life and property. SECTION IX. ARTICLE I. _The duty of the owner of a Distillery._ The main and first object of the proprietor of a distillery, is gain or profit--and the second, it is natural, should be the acquiring a character or reputation for his liquor, and a desire to excel neighboring distilleries--in both of which, neglect and sloth will insure disappointment. The active, cleanly, industrious and attentive proprietor uses the following means. First. He provides his distillery with good sound grain, hogsheads, barrels, kegs, funnels, brooms, malt, hops, wood, &c. of all of which he has in plenty, nicely handled, and in good order. He also provides an hydrometer, thermometer, and particularly a barometer, duly observing the instructions accompanying each, their utility and particular uses. Secondly. He is careful that his distiller does his duty, of which he can be assured only, by rising at four o'clock, winter and summer, to see if the distiller is up and at his business, and that every thing is going well--and to prepare every thing and article necessary--to attend and see the hogs fed, and that the potale or slop be cold when given, and that the cattle be slopped--that the stills are not burning, nor the casks leaking, &c. &c. He observes the barometer, points out any changes in the weather, and pays an unremitted attention, seeing that all things are in perfect order, and enforcing any changes he may deem necessary. On the other hand, indolence begets indolence--The proprietor who sleeps till after sun rise, sets an example to his distiller and people, which is too often followed--the distillery becomes cold from the want of a regular fire being kept up in her--the hogsheads cease to work or ferment, of consequence, they will not turn out so much whiskey--and there is a general injury sustained. And it may often occur, that during one, two or three days in the week, the distiller may want grain, wood, malt, hops or some necessary--and perhaps all those things may be wanting during the same day ... and of course, the distiller stands idle. The cattle, hogs, &c. suffer; and from this irregular mode of managing, I have known the proprietor to sink money, sink in reputation, and rarely ever to attribute the effect to the right cause. _System and Method._ A well timed observance of system and method are necessary in all the various branches of business pursued, and without which none succeeds so well. And whilst the industrious, attentive and cleanly proprietor, may with certainty, calculate on a handsome profit and certain advantages to result from this business. He who conducts carelessly, may as certainly reckon on sustaining a general loss. ART. II. _The duty of an hired Distiller_ Is to rise at four o'clock every morning. Wash and clean out the boiler, fill her up with clean water, put fire under her, and to clean, fill and put fire under the singling still--to collect and put in order for mashing, his hogsheads--and as soon as the water is warm enough in the boiler to begin mashing, which he ought to finish as early in the day as possible; for when the mashing is done, he will have time to scald and clean his vessels, to attend his doubling and singling still, to get in wood for next day, and to make his stock yeast, if new yeast is wanting. In short, the distiller ought to have his mashing finished by twelve o'clock every day, to see and have every thing in the still house, under his eye at the same time; but he ought never to attempt doing more than one thing at once--a distiller ought never to be in a hurry, but always busy. I have always remarked that the bustling unsteady distiller attempts doing two or three things at once, and rarely ever has his business in the same state of forwardness with the steady methodical character. SECTION X. ARTICLE I. _Profits of a Common Distillery._ Profits arising from a distillery with two common stills, one containing 110 gallons, and one containing 65 gallons that is well conducted for 10 months. The calculations predicated on a site, distant about 60 miles from market. Due regard is paid to the rising and falling markets in the following statement. The selling price of whiskey will always regulate the price of grain, the distiller's wages, the prices of malt, hops, hauling, &c. is rather above than below par. _Distillery, Dr._ To 1077 bushels corn, at 50 cents per bushel, is $ 538 50 533 bushels rye, at 60 cents 309 80 96 bushels malt, at 70 ditto 67 20 ______ 1706 bushels total. 60 pounds hops at 25 cents per pound 15 100 cords of wood, at 2 dollars 200 Distiller's wages per year and boarding 204 70 Hauling whiskey, at 4 cents per gallon 204 70 50 poor hogs at 4 dollars each 200 --------- $ 1739 90 _Contra Cr._ By 5118 gallons whiskey, at 59 cents per gallon $ 2559 50 fat hogs at 7 dollars each 350 --------- $ 2939 --------- Leaving a balance of $ 1143 10 I have charged nothing for hauling of grain, &c. as the feed or slop for milk cows, young cattle, and fatting cattle, will more than pay that expense. An estimate of the profits arising from a patent distillery, (col. Anderson's patent improved) 1 still of 110 with a patent head, 1 still of 85 gallons for a doubling still, and a boiler of metal, holding 110 gallons. _Distillery, Dr._ To 2454 bushels corn, at 50 cents per bushel $ 1227 1216 do. rye, at 60 cents do. 729 60 200 do. malt at 70 cents do. 140 --------- 3870 120 pounds hops, at 25 cents per pound 30 100 cords wood, at 2 dollars per cord 200 2 distillers wages, boarding, &c. 400 Hauling whiskey, per gallon at 4 cents 464 40 120 poor hogs at 4 dolls. each 480 ________ Total expense $ 3671 _Contra, Cr._ By 11610 gallons whiskey, at 50 cents per gallon $ 5805 50 120 fat hogs, at 7 dolls. each 840 _________ $ 6645 50 _________ Clear profit, $ 2974 50 Profit of a common distillery 1148 10 _________ Balance in favor of a patent distillery $ 1826 40 _________ To do the business of a patent distillery or to carry her on to advantage, requires a little more capital to start with--but either the patent or common distillery, when they have run two or three months, managed by an attentive and brisk dealing man, will maintain, or keep themselves agoing. Where wood is scarce and money plenty, the patent distillery is certainly to be recommended, indeed, in all cases, I would recommend it, where the proprietor has money enough. It is by far the most profitable, and will sooner or later become in general use in this country. ART. III. _Of Hogs._ Raising, feeding and fattening hogs on potale, a business pursued and highly spoken of, but from my experience I have discovered that few good pigs can be raised entirely on potale--as it has a tendency to gripe and scour too much; but after they are weaned and a little used with slop, they will thrive well. If a hog in a cold morning comes running to a trough full of slop, that is almost boiling, and is very hungry--their nature is so gluttonous & voracious, that it will take several mouthfuls before it feels the effects of the heat, and endangers the scalding of the mouth, throat and entrails--and which may be followed by mortification and death;--moreover, hot feeding is the cause of so many deaths, and ill-looking unhealthy pigs, about some distilleries--which inconvenience might be avoided by taking care to feed or fill the troughs before the boiling slop is let out from the still. A distiller cannot be too careful of his hogs--as with care, they will be found the most productive stock he can raise--and without care unproductive. The offals of distilleries and mills cannot be more advantageously appropriated than in raising of hogs--they are prolific, arrive at maturity in a short period, always in demand. Pork generally sells for more than beef, and the lard commands a higher price than tallow; of the value of pork and every part of this animal, it is unnecessary for me to enter into detail; of their great value and utility, almost every person is well acquainted. The hog pens and troughs ought to be kept clean and in good order, the still slop salted two or three times a week; when fattening, hogs should be kept in a close pen, and in the summer a place provided to wallow in water. Hogs that are fed on potale, ought not to lie out at night, as dew, rain and snow injures them--indeed such is their aversion to bad weather, that when it comes on, or only a heavy shower of rain, away they run, full speed, each endeavoring to be foremost, all continually crying out, until they reach their stye or place of shelter. At the age of nine months, this animal copulates first, and frequently earlier, but it is better engendering should be prevented, till the age of eighteen months--for at an earlier age, the litter is uniformly small, and weakly, and frequently do not survive, besides the growth is injured. It is therefore better not to turn a sow to breeding, till from 18 to 24 months old. The sow goes four months with pig, and yields her litter at the commencement of the fifth; soon after encourages and receives the boar, and thus produces two litters in the year. I have known an instance of three litters having been produced in the year from one female. A sow ought not to be permitted to suckle her pigs more than two or three weeks, after which eight or nine only should be left with her, the rest sold, or sent to market, or killed for use--at the age of three weeks they are fit for eating, if the sow is well fed. A few sows will serve, and those kept for breeding, well selected from the litter, the residue, cut and splayed. Care and pains is due in the choice of the breed of hogs--the breeder had then better procure good ones, and of a good race at once, tho' the expense and trouble may seem material in the outset, yet the keeping will be the same, and the produce perhaps fifty per cent more. After the pigs are weaned, they ought to be fed for the first two weeks on milk, water and bran, after which potale may be used in the room of milk. I would recommend a little mixed potale from an early period, and increase it, so as to render them accustomed to the slop gradually. ART. IV. _Of the Diseases of Hogs._ The only disease that I know of which seems to be peculiar to hogs, is a kind of leprosy, commonly called measles, when it seizes them, they become dull and sleepy, if the tongue is pulled out, the palate and throat will be found full of blackish spots, which appear also on the head, neck, and on the whole body--the creature is scarce able to stand, and the roots of its bristles are bloody. As this disorder proceeds chiefly from their gluttony and filth, and hot drinking of potale and slop; to remedy which, it would be commendable to feed on cold potale, or scarcely milk warm, to keep them clean, to mix salt occasionally with the potale--tar their trough once a month, and give them a little ground antimony. In fattening hogs I have known them improve rapidly, after eating the warm ashes from a fresh burned brush heap. Hickory or willow ashes will have an effect to destroy worms, and I think ought to be used, they will eat it dry, when put in their troughs. ART. V. _On feeding Cattle and Milch Cows._ Potale is a great creator of milk, and will increase the quantity greatly in cows yielding milk, but no so good. Young cattle thrive very well, that get hay or straw during the night. To fatten cattle there ought to be mixed with the slop, a little oil meal, or chopped flaxseed, or chopped corn. The cattle kept on still slop ought to get plenty of salt. Warm potale injures their teeth. SECTION XI. ARTICLE I. _Observations on erecting Distilleries._ Those who are about to erect distilleries, have a handsome subject for consideration; the advantages, and the probable disadvantages that may arise from building on a particular site, or seat. The contiguity to a chopping mill is a material consideration--Wood forming an important article, should be taken into view--Grain merits also a great share of attention. The water which forms, by no means, the least important ingredient should be well analyzed; and a share of thought is due to the subject of a market for the whiskey, spirits and pork, produced from the establishment.--And should the water then prove good, soft and proper for fermentation, can be bro't over head, and the chopping mill is not very inconvenient, and wood convenient and cheap, and grain plenty and at reasonable prices, and a market within one hundred miles, I have little doubt but that with proper economy and observance of system, the establishment will prove very productive; and may be progressed in with cheerfulness, and a reasonable hope of a fair retribution to the owner. A proper seat being fixed on, with sufficient fall to bring the water over head, for it is very material, and an immense saving of labor--material, because it prevents a loss, in running the stills, from pumping or want of water in the cooling tubs. The size of the house follows, as requiring some more than usual calculation--houses are generally made too small, giving great inconvenience, and preventing that nice attention to cleanliness, which forms a very important item in the process of distilling. I would recommend a size sufficiently large for three stills, and to mash six hogsheads per day--one of col. Anderson's patent improved stills, I would consider, in many situations, as most desirable; at all events, I would recommend the preparation of room enough for three stills, if even it should be the intention of the owner to erect but two--for it is very probable, that after some experience, he may determine to pursue the business more extensively, and add the patent still. The size then established, I would recommend the lower story to be 10 feet high, this will leave room for the heated, or rarefied air to ascend in the summer above the cooler, and more necessary air in the warm season of the year, and prevent the unpleasant effect of a too warm air on the mashing hogsheads, and the sowing of the stuff in fermentation--and moreover, prevent the unpleasant effects of smoak on the distillers eyes. But it is important that the house should be erected on level ground with doors opposite each other, with plenty of windows to afford a draft and recourse of air, at pleasure, during the warm season; and so that in the winter it may be closed and preserved perfectly warm--to which end it is most expedient the lower story should be well built with stone and lime, and neatly plastered--the windows well glazed, with shutters &c. Thus provided, and a thermometer placed in the centre of the house, a proper temperature may be kept up in the air of the house--for there is a certain degree of warmth which exceeds for fermentation--this degree of heat, then correctly ascertained by the distiller, he may by a close attention to his duties, fires and the thermometer, always keep the air of the house in nearly that same and most approved state; and even by a well timed observation guard against storms and casualties. To effectuate this grand and important object, some have divided the stills, placing the boiler at one end, and a singling and doubling still at the other; this mode will ensure, in cold weather, the success of the measure more fully--others have placed all the stills in the centre of the building--a plan that will do better in the winter than in the summer, and one I think less favourably of than that of dividing them. During the winter, the north or northwest side of the house should be kept quite close, permitting the house to be lighted from the more temperate southward exposure. To calculate the window sashes to open by hinges, or to be taken entirely out in the summer, at pleasure, is in my mind advisable. SECTION XII. ARTICLE I. _On Wines._ Presuming this work may be rendered more desirable to farmers, from the introduction of some receipts for making domestic wine from the common hedge grapes, or such as are common on fence rows and on high rich grounds, and which are pleasantly flavored after receiving frost, and also for making cider in the best mode for preservation. I have extracted a few from various author's. _Receipt for making Domestic Wine from the Autumn Blue Grape._ About the latter end of September or about the first white frosts, gather the grapes which with us grow along old fences and hedges--pick all the grapes from the stems that are juicy, allowing two bushels thus picked a little heaped, to the barrel. Mash them well between your hands in small parcels, either in earthen pans, or some convenient small vessels--put them when mashed into a tub together, and add a little water so as to soak the pumice.... After stirring them well together, squeeze the pumice out from the liquor with your hands, as clean as you can--then strain the juice through a hair sieve. If the juice seems not all extracted from the pumice at one soaking and squeezing, put water to the pumice and squeeze them over again; take care not to add too much water, lest there should be more than the cask will hold. If after all the ingredients are added, the cask is not full, it may then be filled up with water. To the liquor thus prepared, add two pounds of good, clean, rich low priced brown sugar, per gallon, stirring it in the tub till all the sugar be dissolved; let it remain in the tub, and in a day or two it will ferment, and the scum rise to the top, which must be carefully skimmed off--then put the wine into a clean nice barrel--do not bung it up tight. There is generally a fermentation in it the spring following, when the grape vines are in blossom, but racking it off just before that season will prevent its working too much. If it is wanted to be soon ripe for use, put a quart of good old brandy after it is racked off, to the barrel, and give it air by leaving the bung quite loose. This mode of manufacturing wine for domestic use, is convenient and not expensive to those who have it in their power to manufacture maple sugar. But the nice housewife or husbandmen of ingenuity, will, I fancy, devise some more neat mode of compressing the juice from the grape--as pressing it by the hand, would seem less cleanly, though the fermentation generally cleanses sufficiently. _Currant Wine_ Is managed in the same way. The same quantity of sugar is presumed to answer--The juice is generally well strained thro' cloths, and when well stirred, &c. with the sugar, and neatly racked off, is put by in a loft to ripen, in sweet casks. ART. II. _Directions for making Cider, British mode._ The apples after being thrown into a heap should always be covered from the weather. The later the cider is made the better, as the juice is then more perfectly ripened, and less danger to be feared from fermentation. Nothing does more harm to cider than a mixture of rotten apples with the sound. The apples ought to be ground so close as to break the seeds which gives the liquor an agreeable bitter. The pumice should be pressed through hair bags, and the juice strained through two sieves, the uppermost of hair, the lower of muslin. After this the cider should be put into open casks, when great attention is necessary to discover the exact time in which the pumice still remaining in the juice, rises on the top, which happens from the third to the tenth day, according as the weather is more or less warm. This body does not remain on top more than two hours; consequently, care should be taken to draw off the cider before it sinks, which may be done by means of a plug. When drawn off, the cider is put into casks. Particular attention is again required to prevent the fermentation, when the least inclination towards it is discovered. This may be done by a small quantity of cider spirits, about one gallon to the hogshead. In March the cider should be again drawn off, when all risque of fermentation ceases. Then it should be put into good sweet casks, and in three years from that time, it will be fit for bottling. Old wine casks are to be preferred; those which contain rum are ruinous to cider. Large earthen vessels might be made with or without glazing, which would be preferable to any wooden vessel whatever. When we compare this with the hasty American mode of making cider, it is not to be wondered at that the English cider so infinitely excels ours. ART. III. _The following is a very highly approved American mode of making Cider._ Take care to have every necessary utensil to be made use of in the whole process, perfectly clean and free from every foreign smell. For this purpose, before you begin your work, let your mill, trough and press be made perfectly clean, by thoroughly washing, and if necessary, with scalding water. The casks are another material object, and if musty, or any other bad smell, one end should be taken out, and with shavings burn the inside; then scrub them clean, and put in the head, scald them well afterwards, and drain them perfectly; when dry, bung them tight and keep them in a cool shady place until wanted for use.--The apples should be quite ripe, and all the unripe and rotten ones, leaves, and every other thing that can tend to give the cider any disagreeable taste, carefully separated from them. I have found from careful attention and many experiments, that it is a great advantage to the cider to be separated from the gross parts as soon as possible; for this purpose, I tried several methods: that which I found succeeded the best, I shall now relate, as by following it, I was able to preserve my cider in a sound state, though made in the early part of the season. I took a large pipe, of about 150 gallons, had one of the heads taken out, and on the inside of the other laid on edge, four strips of boards, two inches wide, and on these strips placed a false bottom, filled with gimlet holes, three inches a part. On this false bottom, I put a hair cloth, (old blanket or swingline tow will do) so as to prevent any sand from washing into the space between the true and false bottoms; I procured a quantity of coarse sand, which was carefully washed in repeated waters, until it would not discolor the clean water--then dried the sand, put it in the pipe, on the hair cloth, (coarse blanket or swingline tow,) about 9 inches thick. Thus having every thing in readiness, I went through the process of making, as quick as possible, by having the apples ground fine early in the morning, putting them in the press as fast as they were ground; and then in sufficient quantities pressed out the juice, and put it over the sand in the cask, (having previously bored a gimlet hole in the side of the cask), between the true and false bottoms, in which I introduced a large goose-quill, stopped with another. The pipe was placed so high, as to admit of a cask under it, to receive the liquor as it ran from the quill, which, if rightly managed, will be perfectly fine, and being put away in a cool cellar, and stopped close, will keep well, and prove of an excellent quality. This process is easy, and in every person's power to execute, as the liquor, by being cleared, from its gross feculences, will not run into that violent fermentation, so destructive to the fine vinous flavor, which renders good cider so pleasing a drink. _Query._ Would not a quart of good apple brandy to each barrel of cider, made in this way, prevent any fermentation? But it is generally believed that cider is the better for having undergone a fermentation, becoming then more active and light; cider that has undergone condensation, or has been boiled down until strong, has been found to keep sound some length of time, but it is too heavy and destructive to the appetite, cloying the digesting powers.--And by too frequent use, I fancy, will ultimately produce ague and fevers; and I fear, cider made according to the foregoing receipt, would have a similar effect, but in a lesser degree. I would recommend after a due attention to cleanliness, in the apple mill, trough, press and casks, that the apples be assorted, and having been exposed to the air, under a roof or shed some time, selecting the sound only, that they be ground fine, and let stand soaking in the pumice twelve hours, and then pressed off, through a clean rye straw cheese (being the most common and convenient in the country,) and when flowing from the press, a vessel should be provided, with the bottom full of gimlet holes, in the style of a riddle, on which lay a coarse cloth, then a layer of clean sand, over which a parcel of coarse rye straw, and suffer it to filter thro' this vessel into the large receiving tub; the rye straw will intercept the coarser pieces of pumice, and may be changed frequently--This mode will rid the liquor of all the coarser pieces of pumice--then I would recommend that the cider should be placed in open hogsheads, such as are used for mashing grain in distilleries; those being raised about two feet and an half high on logs or a scaffolding, under a shade or covering--a spile hole bored near the bottom of each, so as to admit a barrel to stand under the spile--in this state, I would recommend it to stand until it undergoes a fermentation, carefully watching the top, and when the pumice is found to have risen, to skim it off carefully, then having previously provided sweet barrels, draw it off by the spile hole, adding from a pint to a quart of apple brandy to each barrel of strong cider, bung it up tight, and store it where the frost will not injure it. In this way, I presume it will keep well--and if the party be so disposed, I would recommend any bottling to be done in April, and during clear weather, though it is safe to bottle immediately after having undergone a thorough fermentation. _The following Receipt to make an excellent American Wine,_ Was communicated to the Burlington Society for promoting domestic manufactures, by Joseph Cooper, Esq. of Gloucester county, state of New Jersey, and ordered to be published;--which, from its extreme simplicity, and economy, shewing the convenience with which a very pleasant, healthful beverage, may be kept by every family in our country, is published in this work. And moreover, as it may have, in some degree, the happy effects of correcting the baneful and pernicious effects of coffee, which is so commonly used for breakfast in our state at present. Coffee, when first introduced, was used as a medicine only, and given only in a well clarified state, and sparingly--both from its soothing and pleasant effect, it become common, and now it is almost the only beverage used at breakfast by the farmers of Pennsylvania, and indeed, people suppose the morning repast is not genteel, unless the board is decorated with this foreign beverage. If it was used in a moderately strong well clarified state, it would be less injurious, but it is too frequently set down in a non descript state, difficult to be named, mixed with the grounds, and so far from clear, as to be entitled to the epithet of muddy, and sweetened with bad sugar, carrying with it to the simply ignorant family, using it in this state, the cause in a great measure of destroying the tone of the stomach, overloading it, and by and by, the introduction of a kind of dumb ague, or chill, followed with a fever, and often creating intermitting and remitting fevers--consequences arising out of the free use of bad provisions--which diseases are oftentimes kept up by the use of this infamously prepared coffee, for when the country people get sick, coffee is too frequently used as the only diet. It is particularly injurious to bilious habits--souring on the stomach, becoming acid, creating acidity, and preventing the glandular juicy supplies from producing the usual fermentation of the food in the stomach--rendering the chyle vitiated, which in its usual route, imparts from the intestines, nourishment to the blood. Thus conveying its baneful properties by this active vehicle, chyle to the blood, rendering it foetid, discoloured and by and by, often as difficult to be named in its adulterated state as the composition which gave rise to it. Had we not very many instances of new diseases--complaints which the most eminent of the medical faculty can with difficulty name, or treat with judgment, without first having made many essays and experiments fatal to the lives of hundreds, which are increasing with every approaching season, and all since the adoption of coffee. (True, the free use of ardent spirits and other luxuries operating on the effects of indolence--of habits, produced by the wealth and independence of our agricultural and commercial people, and growing out of an imitation of the elevated, affluent of society, born to fortune, and the successful professional characters;) a doubt might present itself as to the propriety of attributing many of those new complaints to coffee ... but to a too plentiful use of bad provisions, and an indulgence of bad habits, we must attribute to them. And as badly made coffee is among the most pernicious kinds of food, and particularly when taken in the morning on an empty stomach, and that too made from very green coffee, (dreadfully poisonous when used too frequently before it acquires age and a whiter colour,) it may be condemned with greater propriety. And whilst this beverage is condemned and so highly to be disapproved of, it is well if we can invent a light, pure, active and healthful beverage to be taken freely, between or at meals, calculated in its nature to correct in some degree, the unhappy effects of bad provisions--it is therefore I mention the _Receipt for making Honey Wine._ I put a quantity of the comb from which the honey had been drained, into a tub, to which I add a barrel of cider, immediately from the press; this mixture was well stirred, and left to soak for one night. It was then strained before a fermentation took place, and honey was added until the weight of the liquor was sufficient to bear an egg. It was then put into a barrel, and after the fermentation commenced, the cask was filled every day for three or four days, with water, that the filth might work out of the bung hole. When the fermentation moderated, I put the bung in loosely, lest stopping it tight, might cause the cask to burst.--At the end of five or six weeks the liquor was drawn off into a tub, and the white of eight eggs well beaten up, with a pint of clean sand, were put into it--I then added a gallon of cider spirit, and after mixing the whole well together, I returned it into the cask, which was well cleaned, bunged it tight and placed it in a proper situation for racking it off when fine. In the month of April following, I drew it off for use, and found it equal in my opinion, to almost any foreign wine--in the opinion of many good judges it was superior. This success has induced me to repeat the experiments for three years, and I am persuaded that by using the clean honey, instead of the comb, as above described; such an improvement might be made as would enable the citizens of the United States, to supply themselves with a truly federal and wholesome wine, which would not cost more than twenty cents per gallon, were all the ingredients procured at the market prices, and would have the peculiar advantage over all other wines, hitherto attempted in this country, that it contains no foreign mixture whatever, but is made from ingredients produced on our own farms. [_Columbian Magazine, November_ 1790. Doubtless the foregoing wine will be found strong, and if not well clarified, or rather fined, may be heavy--and therefore will be found excellent when diluted freely with water, and when about to be drank, two thirds of water will be found necessary, and an improvement. Bottling the foregoing wine in April, will certainly render it more excellent, and I fancy it ought to be drank mixed with water, during warm weather, and between meals, as in its pure state it may be found heavy. The gentleman who made the foregoing experiments, drew it off in kegs--this we presume was done to prevent its souring--as cider will suffer, and become hard after broaching the cask, whereas whilst full it remained sound. All American vinous liquors are liable to sour, because we rarely understand or practice the proper mode of manufacturing. Complete cleansing and fermentation is absolutely necessary--and when fermented, it must be well fined, and then drawn off in nice casks, or bottled--bottling is certainly the most effectual, and if a farmer procures as many as three dozen of black bottles, they with three kegs of seven and an half gallons each, will hold the barrel.--The kegs well bunged, will preserve the wine sound, and when a keg is broached, it must be immediately drawn off and bottled. The bottles when emptied, ought to be rinsed and stood up in an airy closet to drain. _To make Elderberry Wine._ _The editor is happy in introducing the following receipts which he is confident is hardly known in America. The great quantities of the Elderberry, which yearly goes to waste, might with very little trouble be manufactured into one of the most wholesome and agreeable wines ever introduced into America._ To every two quarts of berries, add one gallon of water, boil it half an hour, then strain it, and add to every gallon of liquor, two and an half pounds of sugar, then boil it together for half an hour, and skim it well; when cool (not cold) put in a piece of toasted bread, spread thick with brewer's yeast, to ferment. When you put this liquor into the barrel, which must be done the next day, add to every gallon of liquor, one pound of raisins, chopped, and stir all together in the barrel, once every day, for a week, then stop it close. It will not be fit to tap 'till the spring following the making; and the older the better. _To make Elderberry Wine, to drink, made warm, as a Cordial._ Equal quantities of berries and water boiled together, till the berries break, then strain off the liquor, and to every gallon thereof, put three pounds of sugar, and spice, to your palate, boil all up together, let it stand till it becomes cool, (not cold); then put in a piece of toasted bread, spread thick with brewer's yeast, to ferment, and in two or three days, it will be fit to put in the barrel, then stop it close. This will be fit to drink at Christmas, but the older the better. SECTION XIII. ARTICLE I. _To make Rye Malt for Stilling._ Steep it twenty four hours in warm weather, in cold, forty eight, so in proportion as the weather is hot or cold; drain off the water, lay it in your malt cellar, about fifteen inches thick, for twelve hours; then spread it out half that thickness, sprinkling water on it at the same time; after that, it is to be turned three times a day with care, sprinkling water on as before. The thickness of the bed in this stage, must depend on the weather; work it in this way till the sprout is half as long as the grain, then throw it on your withering floor, wither it there for forty eight hours; then put it on your kiln to dry. ART. II. _Of Brewing Beer._ As the following is intended principally for the use of private families, it will be necessary to begin with directions how to choose good Malt; for which, see page 67. _Of the Brewing Vessels._ To a copper that holds 36 gallons, the mash-tub ought to be at least big enough to contain six bushels of malt, and the copper of liquor, and room for mashing or stirring it: The under back, coolers and working tubs, may be rather fitted for the conveniency of the room, than to a particular size; for if one vessel be not sufficient to hold your liquor, you may take a second. _Of cleaning and sweetening Casks & Brewing Vessels._ If a cask, after the beer is drank out, be well stopt to keep out the air, and the lees remaining in it till you want to use it again, you will need only to scald it well, and take care of the hoops before you fill it; but if air gets into a foul empty cask, it will contract an ill scent in spight of scalding. A handful of bruised pepper boiled in the water you scald with, will take out a little musty smell; but the surest way is to take out the head of the cask, and let the cooper shave and burn it a little, and then scald it for use; if you cannot conveniently have a cooper to the cask, get some stone lime, and put about three pound into a barrel, (and proportionally to smaller or bigger vessels) and put to it about six gallons of cold water, bung it up, and shake it about for some time, and afterwards scald it well; or for want of lime, take a linen rag, and dip it in melted brimstone, and fasten one end to the bung, and light the other, and let it hang on the cask. You must give it a little air, else it will not burn; but keep in as much of the sulphur as you can. Scald it afterwards, and you will find no ill smell. If you have new casks, before you fill them, dig places in the earth, and lay them half their depth with their bung holes downward, for a week; and after well scalding them, you may venture to fill them. Another way to proceed, if your brewing vessels are tinged with any ill smell, is to take unflacked lime and water, and with an old broom scrub the vessel whilst the water is hissing, with the lime; and afterwards take all this lime and water away, and put fresh water into the vessel, and throw some bay or common salt into each, and let it stand a day or two; and when you come to brew, scald your vessels, throw into them a little malt-dust or bran; and this will not only finish their sweetening, but stop them from leaking. But since there is so much trouble in getting vessels sweet after they have been neglected, you ought to make all thorough clean after brewing, and once a month to fill your vessels with fair water, and let it off again in two or three days. _Of mashing or raking your Liquors._ Suppose you take six bushels of malt, and two pounds of hops, and would make of it one barrel of strong, and two barrels of small beer. Heat your first copper of liquor for mashing, and strew over it a double handful of bran or malt; by which you will see when it begins to boil; for it will break and curl, and then it is fit to be let off into the mash tub, where it must remain till the steam is quite spent, and you can see your face in it, before you put in your malt; and then you begin to mash, stirring it all the while you are putting in the malt: but keep out about half a bushel dry, which you are to strew over the rest, when you have done stirring it, which will be as soon as you have well mixed it with the liquor, and prevented it from clodding. After the dry malt is laid on, cover your mash tub with cloths, to prevent losing any spirit of the malt, and let it so remain for two hours. Meanwhile have another copper of liquor hot; and at two hours end begin to let off your first wort into the under-back. Receive a pailful of the first running, and throw it again upon the malt.--You will find that the malt has sucked up half of your first copper of liquor; and therefore to make up your quantity of wort for your strong beer, you must gradually lade out of the second copper, and strew bowl after bowl over the malt, giving it time to soak thro', and keeping it running by an easy stream, till you perceive you have about forty gallons, which in boiling and working will be reduced to thirty-six. If you throw into the under-back (whilst you are letting off) about half a pound of hops, it will preserve it from foxing, or growing sour or ropy. Your first wort being all run off, you must soften the tap of the mash tub; and take a copper of hot liquor for your second mashing, stirring up the malt as you did at first, and then cover it close for two hours more. Meanwhile you fill your copper with the first wort, and boil it with the remainder of the two pounds of hops, for an hour and an half, and then lade it off into the coolers. Contrive to receive the hops in a sieve, basket, or thin woolen bag that is sweet and clean; then immediately fill your copper with cold liquor, renew your fire under it, and begin to let off your second wort, throw a handful of hops into the under-back, for the same reason as before: you will want to lade a few bowls full of liquor over the malt to make up the copper full of second wort; and when you have enough, fasten the tap and mash a third time after the same manner, and cover it close for another two hours; and then charge your copper with the second wort, boiling it for an hour with the same hops. By this time you may shift your first wort out of the coolers into a working tub, to make room for the second wort to come into the coolers; and then your copper being empty, you may heat as much liquor as will serve you to lade over the malt, or, by this time, rather grains, to make up your third and last copper of wort, which must be bottled with the same hops over again; and then your coolers are discharged of your second wort, to make room for the third; and when they are both of a proper coolness, they may be put together before you set them a working. During the time of shifting your liquors out of the copper, it is of consequence to take care to preserve it from receiving damage by burning: you should always contrive to have the fire low, or else to damp it at the time of emptying, and be very expeditious to put in fresh liquor. _Of working the Liquor._ In this, regard must be had to the water: liquor naturally grows warm in working; therefore, in mild weather, it should be cold before it be set on, but a little warm in cold weather. The manner of doing it, is to put some good sweet yeast into a hand-bowl or piggin, with a little warm wort; then put the hand-bowl to swim upon the wort in the working tub, and in a little while it will work out, and leisurely mix with the wort, and when you find the yeast is gotten hold of the wort, you must look after it frequently; and if you perceive it begins to heat and ferment too fast, lade some of it out into another tub; and when grown cold, it may be put back again; or if you reserve some of the raw wort, you may check it leisurely, by stirring it in with a hand-bowl. The cooler you work your liquor, the better, provided it does but work well. If you happen to check it too much, you may forward its working, by filling a gallon stone bottle with boiling water, cork it close and put the bottle into the working tub.--An ounce or two of powdered ginger will have the same effect. There are a variety of methods in managing liquors whilst they are working.--Some people beat the yeast of strong beer and ale, once in two or three hours, for two or three days together. This they reckon makes the drink more heady, but withal hardens it so as to be drinkable in two or three days; the last day of beating it in, (stirring the yeast and beer together) the yeast, as it rises, will thicken; and then they take off part of the yeast, and beat in the rest, which they repeat as often as it rises thick; and when it has done working, they tun it up, so as it may just work out of the barrel. Others again do not beat it in at all, but let their strong drink work about two days, or till they see the ferment is over; and then they take off the top yeast, and either by a tap near the bottom, let it off sine, or else lade it out gently, to leave the sediment and yeast at the bottom. This way is proper for liquor that is to be drank soon: but if it be to keep, it will want the sediment to feed upon, and may probably grow stale, unless you make artificial lees: This you may make of a quart of brandy, and as much flour of wheat as will make it into dough; put them in lumps into the bung hole as soon as it has done working. Or else take a pound of the powder of oyster shells and mix it with a pound of treacle or honey, and put it in soon after it has done working. It would add to the goodness, as well as sining of your malt liquor, if you took two quarts of wheat, and make them very dry and crisp in an oven, or before the fire, and boil them in your first copper of wort.--They would strain off with your hops, and might be put with them into the second copper. _Of the fining of Malt Liquors._ It is most desirable to have beer fine of itself, which it seldom fails to do in due time, if rightly brewed and worked; but as disappointments some times happen, it will be necessary to know what to do in such cases. Ivory shavings boiled in your wort, or hartshorn shavings put into your cask just before you bung it down, will do much towards fining and keeping your liquor from growing stale. Isinglass is the most common thing made use of in fining all sorts of liquors; they first beat it well with a hammer or mallet, and lay it in a pail, and then draw off about two gallons of the liquor to be fined upon it, and let it soak two or three days; and when it is soft enough to mix with the liquor, they take a whisk, and stir it about till it is all of a ferment, and white froth; and they frequently add the whites and shells of about a dozen of eggs, which they beat in with it, and put altogether into the cask; then with a clean mop-stick, or some such thing, stir the whole together; and then lay a cloth, or piece of paper over the bung-hole, till the ferment is over; and then bung it up close, in a few days it will fall fine. But if you want to fine only a small quantity, take half an ounce of unflacked lime, and put it into a pint of water, and stir it well together, and let it stand for two or three hours, or till the lime settle to the bottom; then pour the water off clear, and throw away the sediment; then take half an ounce of isinglass cut small, and boil it in the lime water till it dissolves; then let it cool, and pour it into the vessel, &c. _Of the season for Brewing._ The season for brewing keeping-beer is certainly best before Christmas, for then your malt is in perfection, not having time to contract either a musty smell, dust or weavels, (an insect that eats out the heart of the malt) and the waters are then seldom mixed with snow; and then four pounds of hops will go as far as five in the spring of the year: For you must increase in the quantity of hops as you draw towards summer. But, in short, chuse moderate weather as much as you can for brewing, and if you have a kindly cellar besides to keep your liquor in, that will not be much affected by extremity of heat or cold, you may reasonably expect great satisfaction in your brewery. Avoid as much as possible brewing in hot weather; but if you are necessitated to brew, make no more than present drinking, for it will not keep. _To make Elderberry-Beer or Ebulum._ Take a hogshead of the first and strong wort, and boil in the same one bushel of picked Elderberries, full ripe; strain off, and when cold, work the liquor in the hogshead, and not in an open tun or tub; and after it has lain in the cask about a year, bottle it; and it will be a good rich drink, which they call ebulum; and has often been preferred to portwine, for its pleasant taste, and healthful quality. N. B. There is no occasion for the use of sugar in this operation; because the wort has strength and sweetness enough in itself to answer that end; but there should be an infusion of hops added to the liquor, by way of preservation and relish. Some likewise hang a small bag of bruised spices in the vessel. _To make improved and excellent wholesome Purl._ Take Roman wormwood two dozen, gentian-root six pounds; calamus aromatics (or the sweet flag root) two pounds; a pound or two of the galen gale-root; horse radish one bunch; orange peal dried, and juniper berries, each two pounds; seeds or kernels of Seville oranges cleaned and dried, two pounds. These being cut and bruised, put them into a clean butt, and start your mild brown, or pale beer upon them, so as to fill up the vessel, about the beginning of November, and let it stand till the next season; and make it thus annually. _To brew Strong Beer._ To a barrel of beer take two bushels of wheat just cracked in the mill, and some of the flour sifted out of it; when your water is scalding hot, put it into your mash-vat, there let it stand till you can see your face in it; then put your malt upon that, and do not stir it; let it stand two hours and an half; then let it run into a tub that has two pounds of hops in it, and a handful of rosemary flowers; and when it is all run, put it into the copper, and boil it two hours; then strain it off, setting it a cooling very thin, and setting it a working very cool; clear it very well before you put it a working; put a little yeast to it; when the yeast begins to fall, put it into your vessel, put in a pint of whole grain, and six eggs, then stop it; Let it stand a year, and then bottle it. A good table-beer may be made, by mashing again, after the preceding is drawn off; then let it stand two hours, and let that run, and mash again, and stir it as before; be sure to cover your mashing-vat well; mix the first and second running together. _To make China Ale._ To six gallons of ale, take a quarter of a pound or more of China root, thin sliced, and a quarter of a pound of coriander seeds, bruised--hang these in a tiffany, or coarse linen bag, in the vessel, till it has done working; and let it stand fourteen days before you bottle. _To make Ale, or any other liquor, that is too new, or sweet, drink stale._ To do this to the advantage of health, put to every quart of ale, or other liquor, 10 or 12 drops of the true spirit of salt, and let them be well mixed together, which they will soon do it by the subtile spirits penetrating into all parts, and have proper effect. _To recover sour Ale._ Scrape fine chalk a pound, or as the quantity of liquor requires, more; put it into a thin bag into the ale. _To recover Liquor that is turned bad._ If any liquor be pricked or fading, put to it a little syrup of clay, and let it ferment with a little barm, which will recover it; and when it is well settled, bottle it up, put in a clove or two, with a lump of loaf sugar. _Directions for Bottling._ You must have firm corks, boiled in wort, or grounds of beer; fill within an inch of the cork's reach, and beat it in with a mallet; then, with a small brass wire, bind the neck of the bottle, bring up the ends, and twist them over with a pair of pincers. _To make a quarter of a hogshead of Ale, and a hogshead of Beer, of cooked Malt._ Take five strike of malt not ground too small; put in some boiling water, to cover the bottom of your mashing-vat before you put in your malt; mash it with more boiling water, putting in your malt at several times, that it may be sure to be all wet alike; cover it with a peck of wheat bran, then let it stand thus mashed four hours, then draw off three gallons of wort, and pour it upon that you have mashed, so let it stand half an hour more, till it runs clear, then draw of all that will run, and take two quarts of it to begin to work up with the barm, which must be about a pint and a half--put in the two quarts of wort at three times to the barm; you need not stir it till you begin to put in the boiled wort. You will not have enough to fill your vessel at first; wherefore you must pour on more boiling water, immediately after the other has done running, till you have enough to fill a quarter of a hogshead, and then pour on water for a hogshead of beer. As soon as the ale wort has run off, put a third part into the boiler--when it boils up, take off the scum, which you may put upon the grains for the small beer--when it is skimmed, put in a pound and an half of hops, having first sifted out the seeds, then put in all the wort, and let it boil two hours and an half, afterwards strain into two coolers, and let it stand to cool and settle, then put it to cool a little at a time, to the barm, and two quarts of wort, and beat it well together: every time you put the wort in, be sure you keep the settling out. Suppose you brew early on Thursday morning, you may tun it at 9 or 10 on Saturday morning. Do not fill your vessel quite full, but keep about three gallons to put in, when it has worked 24 hours, which will make it work again. As soon as it hath done working, stop it up, put the drink as cool as you can together; thus it will work well. _To make Treacle Beer._ Boil two quarts of water, put into it one pound of treacle or molasses, stir them together till they are well mixed; then put six or eight quarts of cold water to it, and about a tea cup full of yeast or barm, put it up in a clean cask or stein, cover it over with a coarse cloth, two or three times double, it will be fit to drink in two or three days. The second and third time of making, the bottom of the first beer will do instead of yeast. If you make a large quantity, or intend it for keeping, you must put in a handful of hops and another of malt, for it to feed on, and when done working, stop it up close. The above is the best and cheapest way of making treacle beer, tho' some people add raisins, bran, wormwood, spices, such fruit, &c. as are in season, but that is just as you fancy. Indeed many pleasant, cheap, and wholesome drinks may be made from fruits, &c. if they are bruised and boiled in water, before the treacle is added. The plan of manufacturing domestic wines, mead and small beer, once established and understood in a family, becomes easy--is considered a duty--and the females prepare as regularly for renewing them, as for baking, and doing every other branch of business. Many families amidst plenty of ingredients and means, rarely have a comfortable beverage under their roof--this is attributable to indolence, stupidity and want of knowledge.--A little well timed, planning and system, with little more than usual labour, by the intelligent housewife, will cause comfort and plenty to reign throughout, and prove a fine and salutary example to society. Besides, the pleasure a lady derives from presenting a glass of good wine, in a nice clean glass to her welcome visitants, will always amply compensate for the trouble of manufacturing, and preparing it; but when the more intelligent pass a handsome and well merited compliment on the neatness and quality of her fare--she derives happiness from her industry, and a degree of pleasure approaching to exquisite. She may be esteemed one "who hath used her active faculties for the benefit of her family and society, and not only deserves well of society, but of heaven, for the judicious and liberal exercise of the mind, that god-like intellect, among the finest gifts of the munificent creator of worlds." But of her, who sitteth still and inactive, and doth not exercise those intellectual powers, it may be said "she is of an estrayed soul," and "hath buried her talent." And neither merits the attention of society, or the grateful love of her husband and family--and throws herself on the mercy of her God for forgiveness, for her numerous omissions, in withholding the exercise of her active faculties--presuming the being or individual, who is capable of the neglect of one duty, is capable of neglecting all--and tho' some little appearance may be kept up, yet conviction is eternally in the eye of the great judge--and not to be evaded. Thus then the laws of society, morality and religion, requiring the active exercise of our person and faculties--offering the finest and most inducing rewards, the words of our language are capable of describing, in the health afforded from exercise; the example, from which society is benefitted; the pleasure derived from the approbation of our neighbors, and a conscientiousness of having performed our duties here, and living by the exercise of a proper system of economy, in a constant state of independence, always in possession of the means of alleviating the condition of the indigent and unfortunate in society--and relieving the wants of our friends--and above all, the hope of eternal happiness in the approbation of heaven hereafter. _FINIS_ End of Project Gutenberg's The Practical Distiller, by Samuel McHarry *** END OF THIS PROJECT GUTENBERG EBOOK THE PRACTICAL DISTILLER *** ***** This file should be named 21252-8.txt or 21252-8.zip ***** This and all associated files of various formats will be found in: http://www.gutenberg.org/2/1/2/5/21252/ Produced by Robert Cicconetti, Marcia Brooks and the Online Distributed Proofreading Team at http://www.pgdp.net Updated editions will replace the previous one--the old editions will be renamed. Creating the works from public domain print editions means that no one owns a United States copyright in these works, so the Foundation (and you!) can copy and distribute it in the United States without permission and without paying copyright royalties. Special rules, set forth in the General Terms of Use part of this license, apply to copying and distributing Project Gutenberg-tm electronic works to protect the PROJECT GUTENBERG-tm concept and trademark. Project Gutenberg is a registered trademark, and may not be used if you charge for the eBooks, unless you receive specific permission. If you do not charge anything for copies of this eBook, complying with the rules is very easy. You may use this eBook for nearly any purpose such as creation of derivative works, reports, performances and research. They may be modified and printed and given away--you may do practically ANYTHING with public domain eBooks. Redistribution is subject to the trademark license, especially commercial redistribution. *** START: FULL LICENSE *** THE FULL PROJECT GUTENBERG LICENSE PLEASE READ THIS BEFORE YOU DISTRIBUTE OR USE THIS WORK To protect the Project Gutenberg-tm mission of promoting the free distribution of electronic works, by using or distributing this work (or any other work associated in any way with the phrase "Project Gutenberg"), you agree to comply with all the terms of the Full Project Gutenberg-tm License (available with this file or online at http://gutenberg.org/license). Section 1. General Terms of Use and Redistributing Project Gutenberg-tm electronic works 1.A. By reading or using any part of this Project Gutenberg-tm electronic work, you indicate that you have read, understand, agree to and accept all the terms of this license and intellectual property (trademark/copyright) agreement. If you do not agree to abide by all the terms of this agreement, you must cease using and return or destroy all copies of Project Gutenberg-tm electronic works in your possession. If you paid a fee for obtaining a copy of or access to a Project Gutenberg-tm electronic work and you do not agree to be bound by the terms of this agreement, you may obtain a refund from the person or entity to whom you paid the fee as set forth in paragraph 1.E.8. 1.B. "Project Gutenberg" is a registered trademark. It may only be used on or associated in any way with an electronic work by people who agree to be bound by the terms of this agreement. There are a few things that you can do with most Project Gutenberg-tm electronic works even without complying with the full terms of this agreement. See paragraph 1.C below. There are a lot of things you can do with Project Gutenberg-tm electronic works if you follow the terms of this agreement and help preserve free future access to Project Gutenberg-tm electronic works. See paragraph 1.E below. 1.C. The Project Gutenberg Literary Archive Foundation ("the Foundation" or PGLAF), owns a compilation copyright in the collection of Project Gutenberg-tm electronic works. Nearly all the individual works in the collection are in the public domain in the United States. If an individual work is in the public domain in the United States and you are located in the United States, we do not claim a right to prevent you from copying, distributing, performing, displaying or creating derivative works based on the work as long as all references to Project Gutenberg are removed. Of course, we hope that you will support the Project Gutenberg-tm mission of promoting free access to electronic works by freely sharing Project Gutenberg-tm works in compliance with the terms of this agreement for keeping the Project Gutenberg-tm name associated with the work. You can easily comply with the terms of this agreement by keeping this work in the same format with its attached full Project Gutenberg-tm License when you share it without charge with others. 1.D. The copyright laws of the place where you are located also govern what you can do with this work. Copyright laws in most countries are in a constant state of change. If you are outside the United States, check the laws of your country in addition to the terms of this agreement before downloading, copying, displaying, performing, distributing or creating derivative works based on this work or any other Project Gutenberg-tm work. The Foundation makes no representations concerning the copyright status of any work in any country outside the United States. 1.E. Unless you have removed all references to Project Gutenberg: 1.E.1. The following sentence, with active links to, or other immediate access to, the full Project Gutenberg-tm License must appear prominently whenever any copy of a Project Gutenberg-tm work (any work on which the phrase "Project Gutenberg" appears, or with which the phrase "Project Gutenberg" is associated) is accessed, displayed, performed, viewed, copied or distributed: This eBook is for the use of anyone anywhere at no cost and with almost no restrictions whatsoever. You may copy it, give it away or re-use it under the terms of the Project Gutenberg License included with this eBook or online at www.gutenberg.org 1.E.2. If an individual Project Gutenberg-tm electronic work is derived from the public domain (does not contain a notice indicating that it is posted with permission of the copyright holder), the work can be copied and distributed to anyone in the United States without paying any fees or charges. If you are redistributing or providing access to a work with the phrase "Project Gutenberg" associated with or appearing on the work, you must comply either with the requirements of paragraphs 1.E.1 through 1.E.7 or obtain permission for the use of the work and the Project Gutenberg-tm trademark as set forth in paragraphs 1.E.8 or 1.E.9. 1.E.3. If an individual Project Gutenberg-tm electronic work is posted with the permission of the copyright holder, your use and distribution must comply with both paragraphs 1.E.1 through 1.E.7 and any additional terms imposed by the copyright holder. Additional terms will be linked to the Project Gutenberg-tm License for all works posted with the permission of the copyright holder found at the beginning of this work. 1.E.4. Do not unlink or detach or remove the full Project Gutenberg-tm License terms from this work, or any files containing a part of this work or any other work associated with Project Gutenberg-tm. 1.E.5. Do not copy, display, perform, distribute or redistribute this electronic work, or any part of this electronic work, without prominently displaying the sentence set forth in paragraph 1.E.1 with active links or immediate access to the full terms of the Project Gutenberg-tm License. 1.E.6. You may convert to and distribute this work in any binary, compressed, marked up, nonproprietary or proprietary form, including any word processing or hypertext form. However, if you provide access to or distribute copies of a Project Gutenberg-tm work in a format other than "Plain Vanilla ASCII" or other format used in the official version posted on the official Project Gutenberg-tm web site (www.gutenberg.org), you must, at no additional cost, fee or expense to the user, provide a copy, a means of exporting a copy, or a means of obtaining a copy upon request, of the work in its original "Plain Vanilla ASCII" or other form. Any alternate format must include the full Project Gutenberg-tm License as specified in paragraph 1.E.1. 1.E.7. Do not charge a fee for access to, viewing, displaying, performing, copying or distributing any Project Gutenberg-tm works unless you comply with paragraph 1.E.8 or 1.E.9. 1.E.8. You may charge a reasonable fee for copies of or providing access to or distributing Project Gutenberg-tm electronic works provided that - You pay a royalty fee of 20% of the gross profits you derive from the use of Project Gutenberg-tm works calculated using the method you already use to calculate your applicable taxes. The fee is owed to the owner of the Project Gutenberg-tm trademark, but he has agreed to donate royalties under this paragraph to the Project Gutenberg Literary Archive Foundation. Royalty payments must be paid within 60 days following each date on which you prepare (or are legally required to prepare) your periodic tax returns. Royalty payments should be clearly marked as such and sent to the Project Gutenberg Literary Archive Foundation at the address specified in Section 4, "Information about donations to the Project Gutenberg Literary Archive Foundation." - You provide a full refund of any money paid by a user who notifies you in writing (or by e-mail) within 30 days of receipt that s/he does not agree to the terms of the full Project Gutenberg-tm License. You must require such a user to return or destroy all copies of the works possessed in a physical medium and discontinue all use of and all access to other copies of Project Gutenberg-tm works. - You provide, in accordance with paragraph 1.F.3, a full refund of any money paid for a work or a replacement copy, if a defect in the electronic work is discovered and reported to you within 90 days of receipt of the work. - You comply with all other terms of this agreement for free distribution of Project Gutenberg-tm works. 1.E.9. If you wish to charge a fee or distribute a Project Gutenberg-tm electronic work or group of works on different terms than are set forth in this agreement, you must obtain permission in writing from both the Project Gutenberg Literary Archive Foundation and Michael Hart, the owner of the Project Gutenberg-tm trademark. Contact the Foundation as set forth in Section 3 below. 1.F. 1.F.1. Project Gutenberg volunteers and employees expend considerable effort to identify, do copyright research on, transcribe and proofread public domain works in creating the Project Gutenberg-tm collection. Despite these efforts, Project Gutenberg-tm electronic works, and the medium on which they may be stored, may contain "Defects," such as, but not limited to, incomplete, inaccurate or corrupt data, transcription errors, a copyright or other intellectual property infringement, a defective or damaged disk or other medium, a computer virus, or computer codes that damage or cannot be read by your equipment. 1.F.2. LIMITED WARRANTY, DISCLAIMER OF DAMAGES - Except for the "Right of Replacement or Refund" described in paragraph 1.F.3, the Project Gutenberg Literary Archive Foundation, the owner of the Project Gutenberg-tm trademark, and any other party distributing a Project Gutenberg-tm electronic work under this agreement, disclaim all liability to you for damages, costs and expenses, including legal fees. YOU AGREE THAT YOU HAVE NO REMEDIES FOR NEGLIGENCE, STRICT LIABILITY, BREACH OF WARRANTY OR BREACH OF CONTRACT EXCEPT THOSE PROVIDED IN PARAGRAPH F3. YOU AGREE THAT THE FOUNDATION, THE TRADEMARK OWNER, AND ANY DISTRIBUTOR UNDER THIS AGREEMENT WILL NOT BE LIABLE TO YOU FOR ACTUAL, DIRECT, INDIRECT, CONSEQUENTIAL, PUNITIVE OR INCIDENTAL DAMAGES EVEN IF YOU GIVE NOTICE OF THE POSSIBILITY OF SUCH DAMAGE. 1.F.3. LIMITED RIGHT OF REPLACEMENT OR REFUND - If you discover a defect in this electronic work within 90 days of receiving it, you can receive a refund of the money (if any) you paid for it by sending a written explanation to the person you received the work from. If you received the work on a physical medium, you must return the medium with your written explanation. The person or entity that provided you with the defective work may elect to provide a replacement copy in lieu of a refund. If you received the work electronically, the person or entity providing it to you may choose to give you a second opportunity to receive the work electronically in lieu of a refund. If the second copy is also defective, you may demand a refund in writing without further opportunities to fix the problem. 1.F.4. Except for the limited right of replacement or refund set forth in paragraph 1.F.3, this work is provided to you 'AS-IS' WITH NO OTHER WARRANTIES OF ANY KIND, EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO WARRANTIES OF MERCHANTIBILITY OR FITNESS FOR ANY PURPOSE. 1.F.5. Some states do not allow disclaimers of certain implied warranties or the exclusion or limitation of certain types of damages. If any disclaimer or limitation set forth in this agreement violates the law of the state applicable to this agreement, the agreement shall be interpreted to make the maximum disclaimer or limitation permitted by the applicable state law. The invalidity or unenforceability of any provision of this agreement shall not void the remaining provisions. 1.F.6. INDEMNITY - You agree to indemnify and hold the Foundation, the trademark owner, any agent or employee of the Foundation, anyone providing copies of Project Gutenberg-tm electronic works in accordance with this agreement, and any volunteers associated with the production, promotion and distribution of Project Gutenberg-tm electronic works, harmless from all liability, costs and expenses, including legal fees, that arise directly or indirectly from any of the following which you do or cause to occur: (a) distribution of this or any Project Gutenberg-tm work, (b) alteration, modification, or additions or deletions to any Project Gutenberg-tm work, and (c) any Defect you cause. Section 2. Information about the Mission of Project Gutenberg-tm Project Gutenberg-tm is synonymous with the free distribution of electronic works in formats readable by the widest variety of computers including obsolete, old, middle-aged and new computers. It exists because of the efforts of hundreds of volunteers and donations from people in all walks of life. Volunteers and financial support to provide volunteers with the assistance they need, is critical to reaching Project Gutenberg-tm's goals and ensuring that the Project Gutenberg-tm collection will remain freely available for generations to come. In 2001, the Project Gutenberg Literary Archive Foundation was created to provide a secure and permanent future for Project Gutenberg-tm and future generations. To learn more about the Project Gutenberg Literary Archive Foundation and how your efforts and donations can help, see Sections 3 and 4 and the Foundation web page at http://www.pglaf.org. Section 3. Information about the Project Gutenberg Literary Archive Foundation The Project Gutenberg Literary Archive Foundation is a non profit 501(c)(3) educational corporation organized under the laws of the state of Mississippi and granted tax exempt status by the Internal Revenue Service. The Foundation's EIN or federal tax identification number is 64-6221541. Its 501(c)(3) letter is posted at http://pglaf.org/fundraising. Contributions to the Project Gutenberg Literary Archive Foundation are tax deductible to the full extent permitted by U.S. federal laws and your state's laws. The Foundation's principal office is located at 4557 Melan Dr. S. Fairbanks, AK, 99712., but its volunteers and employees are scattered throughout numerous locations. Its business office is located at 809 North 1500 West, Salt Lake City, UT 84116, (801) 596-1887, email business@pglaf.org. Email contact links and up to date contact information can be found at the Foundation's web site and official page at http://pglaf.org For additional contact information: Dr. Gregory B. Newby Chief Executive and Director gbnewby@pglaf.org Section 4. Information about Donations to the Project Gutenberg Literary Archive Foundation Project Gutenberg-tm depends upon and cannot survive without wide spread public support and donations to carry out its mission of increasing the number of public domain and licensed works that can be freely distributed in machine readable form accessible by the widest array of equipment including outdated equipment. Many small donations ($1 to $5,000) are particularly important to maintaining tax exempt status with the IRS. The Foundation is committed to complying with the laws regulating charities and charitable donations in all 50 states of the United States. Compliance requirements are not uniform and it takes a considerable effort, much paperwork and many fees to meet and keep up with these requirements. We do not solicit donations in locations where we have not received written confirmation of compliance. To SEND DONATIONS or determine the status of compliance for any particular state visit http://pglaf.org While we cannot and do not solicit contributions from states where we have not met the solicitation requirements, we know of no prohibition against accepting unsolicited donations from donors in such states who approach us with offers to donate. International donations are gratefully accepted, but we cannot make any statements concerning tax treatment of donations received from outside the United States. U.S. laws alone swamp our small staff. Please check the Project Gutenberg Web pages for current donation methods and addresses. Donations are accepted in a number of other ways including checks, online payments and credit card donations. To donate, please visit: http://pglaf.org/donate Section 5. General Information About Project Gutenberg-tm electronic works. Professor Michael S. Hart is the originator of the Project Gutenberg-tm concept of a library of electronic works that could be freely shared with anyone. For thirty years, he produced and distributed Project Gutenberg-tm eBooks with only a loose network of volunteer support. Project Gutenberg-tm eBooks are often created from several printed editions, all of which are confirmed as Public Domain in the U.S. unless a copyright notice is included. Thus, we do not necessarily keep eBooks in compliance with any particular paper edition. Most people start at our Web site which has the main PG search facility: http://www.gutenberg.org This Web site includes information about Project Gutenberg-tm, including how to make donations to the Project Gutenberg Literary Archive Foundation, how to help produce our new eBooks, and how to subscribe to our email newsletter to hear about new eBooks.